2017 Buick Encore

The contact owns a 2017 Buick Encore. The contact stated that while driving approximately 25 MPH, the contact smelled smoke and became aware that the smoke was coming from under the hood. The failure reoccurred while driving the following day. The vehicle was driven to an independent mechanic, where it was diagnosed, and it was determined that the turbocharger needed to be replaced. The vehicle was repaired. The contact received notification of Special Coverage: N232395330 (Turbocharger Replacement), and the manufacturer was contacted for reimbursement. A case was opened; however, the manufacturer later informed the contact that the reimbursement claim was denied because the vehicle was not repaired by a dealer. The failure mileage was approximately 48,000.

Wipers will not shut off.

4/2025-Engine coolant water outlet needed to be replaced 5/2025- Turbo boost replaced (under recall) 6/2025- Engine fan needed to be replaced 12/2025- There was active leaking in the engine oil cooler and lines- needed to be replaced Engine ventilation , engine oil weep along valve cover seals- needed to be replaced

I have went to the dealership for the past two years with this problem and they keep saying they are not getting any codes: when the air conditioner is on it’s pulling the power from the motor and makes it hard to go up hill. Hard To accelerate when going on to the freeway as well. The problem is only getting worse and worse.

The turbo charge is not providing adequate power. I was on the highway and the car began to chugging then accelerated on its own and all the lights on the dash came on then all went off like it was going to shut down. I put my hazards on and started to pull to the side of the highway. I gave it a moment for the car and for me because I was terrified, my kids were in the car and traffic was going steady around 70-75 miles per hour and I was scared as it began to shut down that I would be hit by traffic behind me before I could get over. It started driving again. It still drives but is hard to accelerate and even when stopped you can see the RPM rising. It’s as if the car never idles, it feels as though is constantly under load. I have had it looked at professionally at Midas but they will only say they think it is the turbo as there are no codes coming up. I have had it looked at by mechanics I know who have fixed other things that may cause similar issues and nothing has worked and they also believe it is the turbo. I’ve know other people with Buicks and they have had similar problems I’m confused as to why this 1.4 liter turbo has not been recalled.

The contact owns a 2017 Buick Encore. The contact stated while driving at various speeds, the engine overheated, and there was smoke coming from the front of the vehicle. The contact stated that the temperature gauge indicated that the engine was hot. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed and the contact was informed that the water outlet housing, the blower motor, A/C condenser, water pump, thermostat, thermostat housing, turbo charger, and the fan were faulty and needed to be replaced. The vehicle was repaired; however, the failure persisted. The manufacturer was notified of the failure. The approximate failure mileage was 60,189.

The contact owns a 2017 Buick Encore. The contact stated that the front passenger’s side seat belt failed to work as intended. No warning lights were illuminated. The front driver’s side seat belt also failed to work as intended. The contact had to push the front seat all the way back to release the seat belt. The contact stated that the seat belt was too tight and pressed into her stomach. No warning lights were illuminated. The contact had become aware of the failure after the vehicle was purchased. The contact stated that the failure persisted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

While traveling at approximately 77 mph on the interstate, I was forced off the road by another vehicle, causing my car to collide with a cable barrier. The initial impact was to the front driver’s side corner, and the vehicle then scraped along the driver’s side against the barrier. Despite the high-speed impact, no airbags deployed. •Component or System That Failed: The frontal airbag system failed to deploy. •Safety Risk: The non-deployment of the airbags at this speed and impact angle posed a serious risk to my safety. The lack of airbag activation during a high-speed frontal crash greatly increased the likelihood of injury. •Has the Problem Been Reproduced or Confirmed by a Dealer or Independent Shop? No. The vehicle has not yet been inspected by a dealership or repair facility, and the issue has not been confirmed or diagnosed by a professional. •Has the Vehicle or Component Been Inspected by Manufacturer, Police, Insurance, or Others? No. The vehicle has not been inspected by the manufacturer, police, insurance representatives, or any other party as of this report. •Warning Lamps, Messages, or Symptoms Before the Incident: No warning lights or messages were active before the crash. There were no known symptoms or alerts indicating a problem with the airbag system.

Steering wheel locked up, had to replace rack and pinion, locking up when turning, therefore needing a wheel alignment.

The contact owns a 2017 Buick Encore. The contact stated while driving at approximately 45 MPH, the accelerator pedal was depressed, and the vehicle hesitated with the check engine warning light illuminated. The contact stated that the vehicle lost motive power and then suddenly jerked forward. The contact had taken the vehicle to a local dealer where it was diagnosed and determined that the turbocharger was failing and needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The contact researched online and related the failure to Special Coverage Turbocharger Replacement: N232395330; however, the VIN was not included. The failure mileage was approximately 118,000.

First the car started to act odd, jumpy or you could tell there was issues with the turbo. On [XXX] car overheated??? Out of nowhere. Mileage 82049. No warnings, no lights. We had it towed to shop where we were told we need new turbo, new engine, power steering service, ac service. The total Cost was $6813.54. We had to take out 2 loans - 90 days same as cash then 145% interest as well as pay $243.54 in Cash. We were guaranteed the car was in great condition. We picked it up on 1/24/25. Then on [XXX] - Odometer reading 82509 - We pulled over on the side of the road to grab something from the trunk. Driver got back in car and all of a sudden the car just shut down saying overheated and smoke was coming out of the hood. Again, Absolutely no warning, no lights, no weird noises, nothing! We are now stuck in the middle of nowhere with our [XXX] granddaughter. Thank God a police man drove by. The next day we had to have it towed back to shop. Once back to the shop we were told that the engine or labor that they just put in our vehicle would not be covered by warranty. Nothing was fixed!!! I contacted the attorney general. We went to pick it up on 3/28/2025. Once they got involved the shop agreed to do all repairs for $1873.96. (pay $600 now and then post date 2 more checks). The owners said they looked over everything and nothing should be going wrong. It should be good as new. On [XXX] We were on our way to Puerto Penasco Mexico where we have a vacation home. About 20 miles into Mexico the car just stopped. Tons of Smoke from the tail pipe, Low oil pressure all of a sudden came on. I am attaching pics showing that the car was not showing overheated. So now my husband and i are stuck on the side of the road in Mexico with no cell phone service with a [XXX] car that we can not get fixed no matter how much money or time we put into it. When we finally got ahold of the shop they said they are washing their hands of it and do not want to see this car again. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2017 Buick Encore. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the engine needed to be replaced. The vehicle was repaired; however, the failure persisted. The manufacturer was not notified of the failure. The failure mileage was approximately 85,000.