Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 1996 Chevrolet Corvette.
| Trim | City | Hwy | Combined | Annual fuel $ |
|---|---|---|---|---|
| 5.7L 8 cyl Automatic 4-spd | 15 | 23 | 18 | $3,300 |
| 5.7L 8 cyl Manual 6-spd | 15 | 24 | 18 | $3,850 |
NHTSA has not published 5-star crash-test ratings for the 1996 Chevrolet Corvette. New vehicles are often added to the NCAP rating program after initial release; check nhtsa.gov/ratings for the latest status.
Component: FUEL SYSTEM, GASOLINE
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
APPEARS THE ASR UNIT HARD SHORTED SENDING ELECTRICITY THROUGH ALL 3 THROTTLE CABLES AND SEBSEQUENTLY MELTING THEM. THANKFULLY THE VEHICLE DIDN'T START ON FIRE. THIS PROBLEM OCCURRED ON THE FIRST DRIVE OF THE DAY AFTER ABOUT 7 MINUTES OF LOW SPEED (CITY) OPERATION SINCE ENGINE START.
TRIED TO START VEHICLE, BUT 'SECURITY' LIGHT CAME ON & ENGINE WOULD NOT TURN OVER. RESEARCHED ISSUE ONLINE & FOUND THAT THIS IS DUE TO A KNOWN IGNITION LOCK CYLINDER PROBLEM. THE WIRES LEADING TO THE IGNITION LOCK CYLINDER BREAK, AND WILL NOT ALLOW THE ANTI-THEFT SYSTEM TO PROPERLY READ THE SECURITY CODE FROM THE KEY. *TR
TL*THE CONTACT OWNS A 1996 CHEVROLET CORVETTE. WHILE DRIVING APPROXIMATELY 50 MPH ON NORMAL ROAD CONDITIONS, THE CONTACT HEARD A LOUD WHISTLING NOISE. SUDDENLY, THE REMOVABLE ROOF PANEL SEPARATED FROM THE MOUNTING FRAME OF THE VEHICLE. THE DRIVER PULLED OVER TO THE SIDE OF THE ROAD TO INSPECT THE VEHICLE. HE TOOK THE VEHICLE TO AN AUTHORIZED DEALER AND THEY STATED THAT THE FAILURE WAS CONTRIBUTED TO THE ACRYLIC REMOVABLE ROOF PANEL, WHICH WAS REPLACED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR IDENTICAL FAILURES ON FOUR SEPARATE OCCASIONS. THE MANUFACTURER WAS NOTIFIED OF THE MALFUNCTIONS. THE FAILURE MILEAGE WAS 71,500 AND CURRENT MILEAGE WAS 72,500.
The 1996 Chevrolet Corvette has 1 NHTSA recall and 47 consumer complaints on file. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
THE ACRYLIC TOP ON MY 1996 CORVETTE WAS REPLACED WITH A NEW ACRYLIC TOP FROM CHEVROLET. THE ACRYLIC PORTION OF THE TOP HAS SEPARATED FROM THE ALUMINUM MOUNTING FRAME. I HAVE PRESENTED GONE THROUGH 4 CONSECUTIVE TOPS. EVERY TOP SUPPLIED TO ME HAS DONE THE SAME THING. I CAN NO LONGER DRIVE MY VEHICLE DUE TO THIS FACT. IF I CONTINUE TO DRIVE MY VEHICLE, THERE IS A HIGH PROBABILITY THAT MY ROOF IS GOING TO COME OFF OF THE VEHICLE AND POSSIBLY CAUSE A ACCIDENT ON INJURE SOMEONE. *TR
TL*THE CONTACT OWNS A 1996 CHEVROLET CORVETTE. THE CONTACT HEARD A VERY LOUD EXPLOSION AND HER HOME BEGAN TO SHAKE. SHE FOUND THE VEHICLE PARKED IN THE DRIVEWAY ENGULFED IN FLAMES. THE FIRE SPREAD RAPIDLY AS THE FIRE DEPARTMENT WAS CALLED TO THE SCENE. THE FIRE WAS EXTINGUISHED PRIOR TO THE FIRE DEPARTMENT'S ARRIVAL. A POLICE REPORT WAS FILED. UPON FURTHER INVESTIGATION, IT WAS DISCOVERED THAT THE REGULATOR EXPLODED DUE TO PRESSURE BUILD-UP. THE VEHICLE WAS DESTROYED. THE FAILURE AND CURRENT MILEAGES WERE 100,000. UPDATED 03/17/09. *LJ THE FIRE DEPARTMENT WAS UNABLE TO DETERMINE THE CAUSE OF THE FIRE. UPDATED 03/18/09. *JB
SNAP IN VALVE STEM HTTP://BLOGS.CONSUMERREPORTS.ORG/SAFETY/2008/06/TIRE-VALVE-STEM.HTML. *TR
UPON NORMAL AUTO START SEQUENCE, STARTER WOULD NOT DISENGAGE. REMOVED KEY FROM VEHICLE CYLINDER LOCK AND STARTER CONTINUED TO CRANK ENGINE. STARTER MOTOR BEGAN TO SMOKE AND CAUGHT FIRE BEFORE BATTERY COULD BE DISCONNECTED TO REMOVE POWER FROM VEHICLE. BURNED UP STARTER MOTOR AND O2 WIRING HARNESS AROUND LOCATION OF STARTER MOTOR. SAME FAILURE OCCURRED IN 1999. *TR
PASSIVE KEYLESS ENTRY LIGHT CAME ON AND THEN WHILE VEHICLE WAS MOVING HATCH RELEASED. ALTMOST LOSING CONTROL OF VEHICLE. *JB
WHILE OPERATING VEHICLE AT 10 MPH BRAKE PEDAL FELL TO FLOOR AFTER CONSUMER TOOK FOOT OFF BRAKE. HE WAS ABLE TO STOP VEHICLE WITHOUT AN INCIDENT. DEALERSHIP EXAMINED VEHICLE AND DETERMINED THAT BRAKE LINES HAD CORRODED, ALLOWING FAILURE OF BRAKE SYSTEM. *AK *JB
CHECK ENGINE LIGHT ON / DISTRIBUTOR FAILED WHILE DRIVING, ENGINE STALLED, LOST POWER STEERING. ENGINE REFIRED. ON WAY TO DEALER ENGINE STALLED IN TRAFFIC.*AK
VEHICLE CAUGHT ON FIRE IN GARAGE DUE TO ELECTRICAL FAULT IN FACTORY WIRING. FIRE ORIGINATED ON DRIVER'S SIDE OF ENGINE COMPARTMENT. *AK
THE TIRE PRESSURE SENSOR (THE LEFT FRONT SENSOR, ALSO KNOWN AS GREEN #44 OR PART NUMBER 1016 1856) IS NOT AVAILABLE NEW OR USED ANYWHERE IN THE COUNTRY. REFERRING TO PAGE 6-47 OF THE MANUAL, THE FOLLOWING WARNING APPEARS: WHEN THE LOW/FLAT TIRE WARNING LIGHT IS ON YOUR VEHICLE'S HANDLING CAPABILITIES WILL BE REDUCED DURING SEVERE MANEUVERS. IF YOU DRIVE TOO FAST, YOU COULD LOSE CONTROL OF YOUR VEHICLE. YOU OR OTHERS COULD BE INJURED. DON'T DRIVE OVER 55 MPH (90 KM/H) WHEN THE LOW/FLAT TIRE WARNING LIGHT IS ON. DRIVE CAUTIOUSLY AND CHECK YOUR TIRE PRESSURE AS SOON AS YOU CAN." NOW, NOTING THE RECENT HEADLINES ABOUT FIRESTONE TIRE FAILURES AND THE RESULTING TRAGIC CONSEQUENCES, IT WOULD SEEM HIGHLY APPROPRIATE FOR CHEVROLET TO IMMEDIATELY ADDRESS THE FACT THAT THIS PART IS DISCONTINUED AND NO LONGER AVAILABLE. BASICALLY, ALL WE (MY WIFE JOY RENDE, WHO ACTUALLY OWNS THE CAR, AND I) ARE LOOKING FOR IS FOR CHEVY TO START MANURAFTURING THE PART AGAIN.*AK
STEERING GOES OUT INTERMITTENTLY. DEALER REPLACED POWER STEERING RACK AND PUMP, PROBLEM STILL THERE. *AK
CAR WAS VEERING OUT OF CONTROL-AT 45MPH, IN A ONE LANE WORK ZONE. TIRE RIPPED RIGHT DOWN THE MIDDLE-NEARLY SPLIITING IN HALF. YOU COULD SEE RIGHT TROUGH TO THE BRAKES. INSIDE OF TIRE UNRAVELLED-RUBBER HANGING. *AK (DOT NUMBER: M6Y2 6BDR TIRESIZE: P25545ZR17)
LEFT REAR TIRE BLEW OUT ,BELT TREADPACKAGE SEPERATED TOTALLY,LEAVING BEAD/SIDEWALL ONLY ON RIM( DOT NUMBER: TIRE SIZE: P28540ZR17 )
Showing 15 of 47 complaints