Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2003 Chrysler PT Cruiser.
| Trim | City | Hwy | Combined | Annual fuel $ |
|---|---|---|---|---|
| 2.4L 4 cyl Automatic 4-spd | 17 | 23 | 19 | $3,650 |
| 2.4L 4 cyl Automatic 4-spd | 17 | 23 | 20 | $3,000 |
| 2.4L 4 cyl Manual 5-spd | 18 | 25 | 21 | $3,300 |
| 2.4L 4 cyl Manual 5-spd | 19 | 26 | 22 | $2,700 |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: SUSPENSION
FEDERAL MOGUL IS RECALLING 6,903 AFTERMARKET BALL JOINT ASSEMBLIES SHIPPED BETWEEN NOVEMBER 9, 2007 AND MARCH 26, 2008, WHICH MAY HAVE BEEN PACKAGED WITH INCORRECT NUTS. THE PART NUMBERS PACKAGED WITH INCORRECT NUTS ARE: K7147, K7329, K8683, AND 104353. THESE PARTS WERE MADE FOR USE ON THE VARIOUS VEHICLES LISTED ABOVE.
Consequence: THE NUTS INCLUDED IN THE PACKAGING FOR THESE BALL JOINT ASSEMBLIES ARE MISSING THE INTENDED PREVAILING TORQUE (SELF-LOCKING) FEATURE. IF THE INCORRECT NUT WAS TO BECOME LOOSE, THE JOINING MEMBERS MAY LOOSEN LEADING TO A SEPARATION OF THE BALL JOINT. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: FEDERAL MOGUL WILL NOTIFY OWNERS AND REPLACE THE PARTS FREE OF CHARGE. THE RECALL BEGAN ON MAY 22, 2008. OWNERS CAN CONTACT FEDERAL MOGUL AT 877-489-6659.
Component: EXTERIOR LIGHTING
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
WHen the fog lights are engaged, smoke and burning smell appears to be coming inside the steering wheel on the left side.
The clutch will not disengage every time and never fully disengages. I noticed my car had a recall for this problem in the past, so before doing the work, I called a dealer for Chrysler and was informed that the recall had already been performed. So I took it upon myself at my own expense to have the clutch replaced. It worked fine for a few months, but it started doing the same thing again.
The contact owns a 2003 Chrysler equipped with Douglas, Tire line: Dug Xtra-Trac II, Tire size: 205/55R/16 91T and DOT number: N60FN11R. The contact stated that while driving at an undisclosed speed, the contact noticed that the vehicle started to perform slowly when the front passenger side tire inadvertently exploded. No warning lights illuminated. The vehicle was taken to Walmart where the tire was replaced. The contact stated that the front passenger side tire started to leak air. The contact then stated that she noticed that a bubble had developed on the sidewall of the tire. The vehicle was not diagnosed or repaired. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 157920.
The 2003 Chrysler PT Cruiser has 4 NHTSA recalls and 257 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Component: POWER TRAIN:CLUTCH ASSEMBLY
ON CERTAIN PASSENGER VEHICLES, MANUAL TRANSMISSION MODELS ONLY, A WELDED PIN INTERNAL TO THE DUAL-MASS FLYWHEEL (DMF) ASSEMBLY CAN UNSEAT AND BECOME LODGED BETWEEN THE FLYWHEEL AND THE CLUTCH DISC.
Consequence: IF THIS OCCURS, THE CLUTCH MAY NOT DISENGAGE WHEN THE CLUTCH PEDAL IS DEPRESSED.
Remedy: DEALERS WILL REPLACE THE FLYWHEEL AND CLUTCH ASSEMBLIES WITH THE UPDATED DESIGN PARTS. OWNER NOTIFICATION BEGAN ON APRIL 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
On the way home from work my vehicle began smoking. The next exit off the freeway I80 was taken. As I exited my vehicle became hard to steer. I was able to get it to the closest auto repair shop which was Firestone. The power steering hose had a leak which caused the smoke and my vehicle being hard to steer. After 3 attempts with Firestone and them consulting with Chyrsler Service Department in Fairflied, California I had my vehicle towed to my mechanic. He also had trouble getting the new hose to fit on my vehicle. My mechanic also consulted with the Chrysler Service Department in Antioch, California. They assured him that was the correct replacement hose that Chrysler had replaced because the original hose had been recalled and they no longer carried the orignal hose. The only problem is my mechanic nor the Firestone mechanics could get it to fit. I have contacted Chrysler several times with them not taking reponsibility for the non fitting hose as the claim my VIN is not one of the vehicles affected. Attached you will find the original recall notice sent to me in 2011, the letter I sent to the address on the recall notice and all the receipts of attempts to fix my vehicle. The letter I sent to the address on the recall notice was returned as "unable to forward". I'm hoping other PTs with VIN not listed had the same problem as I and can cause Chrysler to repair and reimburse such vehicles.
Was warming my car up and drove 2 miles to my mom's house and turned it off. Came out about 30 minutes later and the car was full of smoke. Aired out the car and noticed a burnt hole in the middle of the passenger seat. The seat warmer had malfunction and started the seat on fire. Even with the vehicle turned off.
I REPLACED MY VEHICLES BATTERY 2 DAYS AGO(NOV 12, 2019)(VERY OLD BATTERY AND WITH THE COLD IN MASSACHUSETTS IT NEEDED TO BE CHANGED). NOW WITH A PROPERLY FUNCTIONING BATTERY THE VOLTAGE REGULATOR IN PCM (NOT ALTERNATOR) IS SIGNALING ALTERNATOR TO RAISE CHARGING VOLTAGE INTERMITTENTLY TO AS HIGH AS 17.1VOLTS, BUT HAS BEEN FREQUENTLY BOUNCING BETWEEN 14.1V -16.7VOLTS. THIS INCREASE OF VOLTAGE TO A UNSAFE LEVEL CAUSES ALL ELECTRICAL ACCESSORIES THAT ARE IN CONNECTED TO THE CHARGING SYSTEM AND ARE OPERATIONAL TO FLASH/ FLICKER. EXTREMELY DISTRACTING AT NIGHT WITH HEADLIGHTS AND DASHBOARD FLASHING/ FLICKERING. AFTER A LOT OF RESEARCH I FOUND OUT THE PCM NEEDS TO BE REPROGRAMMED WITH THE PROPER UPDATED FIRMWARE IN ORDER TO FIX THE FACTORY WEAK PARAMETERS. I SPOKE WITH A SERVICE MANAGER TODAY(NOV 14,2019) AT MY LOCAL CHRYSLER DEALERSHIP (CENTRAL JEEP CHRYSLER DODGE RAM FIAT @ 56 BOSTON PROVIDENCE TPKE, NORWOOD, MA 02062) ABOUT THE PROBLEM AND ASKED TO HAVE MY PCM REPROGRAMMED SINCE ONLY THAT SPECIFIC MODEL CAR MANUFACTURES SERVICE SHOP WILL HAVE THE CAPABILITY AND PCM FIRMWARE TO REPAIR IT. THE MANAGER REFUSED TO DO ANY WORK ON MY CAR SINCE HE SAID, "I WONT TOUCH CARS OLDER THAN 10YEARS AND CLOSE TO 100,000MILES". THEN ASKED IF I WAS EVEN A CUSTOMER AT THAT SPECIFIC LOCATION, SAYING NO AGAIN AFTER I SAID I WASN'T. THERE IS NO OTHER OPTION THAN THE FACTORY DEALERSHIP TO FIX A FACTORY FLAWED PCM, WHICH MAKES THE RISK OF MY BATTERY EXPLODING DUE TO THE INCREASED REGULATED VOLTAGE VERY LIKELY. THIS PROBLEM ISN'T NEW TO CHRYSLER SINCE THEY HAVE ISSUED SEVERAL TSB(S) IN MY SPECIFIC VEHICLE AND THIS EXACT PROBLEM: 18-112-16 18-026-03 REV.A 18-016-03 18-020-04
THERE WAS AN ELECTRICAL FIRE WHERE THE RADIO CUP HOLDERS AND THE SHIFTER. CAR IS UNDRIVEABLE DUE TO THE DAMAGE. MY CAR WAS STATIONARY AT THE TIME. THE RADIO KEPT TURN ON AND OFF. I HEARD CRACKING WHEN I WENT INTO WORK. WHEN I CAME OUT I SAY THERE WAS A WHOLE LOT OF DAMAGE. I DID GET THE CAR STARTED AND WAS ABLE TO GET IT HOME, BUT IT'S NOT DRIVABLE SINCE THE CAR DIED AS I WAS PULLING INTO MY DRIVEWAY. WHEN I WENT TO PUT IT INTO PARK IT WAS LIKE PARK WAS NOT AN OPTION. AMD THE CAR KEPT MOVING SO I PUT THE E BREAK ON.
MY EXTERIOR FRONT LIGHTS ARE VERY DULL AND AREN'T BRIGHT WHEN TURN THEM ON.
I DON'T TRULY KNOW WHAT'S HAPPEN TO IT N IF IT'S BEEN FIXED BUT I DO KNOW THAT PRIOR IT WOULD HAVE UNCONTROLLABLE SPEED CONTROL N STEERING PROBLEMS N GPS N VIDEO N AUTO RECORDING N RADIO FREQUENCIES.
VEHICLE IS LEAKING POWER STEERING FLUID. FOUND RECALL NOTICE FOR MY YEAR MODEL BUT CHRYSLER SAYS MY VIN IS NOT INCLUDED IN THE RECALL. ADDED FLUID ABOUT 3 MONTHS AGO AND STEERING WAS FINE UNTIL A WEEK AGO. SINCE THEN, FLUID ONLY LASTS A DAY BEFORE IT HAS TO BE REFILLED.
VEHICLE WAS PARKED. TURNED OFF. MULTIFUNCTION SWITCH THAT HAD BEEN REPLACED PREVIOULSY MALFUNCTIONED AGAIN. FOG LIGHTS JUST CAME ON OUT OF NOWHERE LUCKILY I TURNED AROUND AND NOTICED IT. WHEN I OPENED MY CAR DOOR I NOTICED THE SWITCH WAS SMOKING. AFTER SOME QUICK THINKING I PULLED THE FUSE. IF I HAD NOT THOUGHT OF THIS I BELIVE IT WOULD HAVE CAUGHT MY CAR ON FIRE AND THE ONES PARKED NEXT TO IT. I HAVE HAD THE FUSE PULLED FOR A YEAR. FLASH FORWARD TO MY CURRENT STATE IN VA AND IT'S INSPECTION TIME. I FAILED FOR A FAULTY FUNCTION SWITCH. THE GUYS REPLACED THE SWITCH FIRST STOPLIGHT I COME TO NO SIGNAL. TOOK IT BACK TO GARAGE THEY SAID SWITCH WAS BAD OUT OF THE BOX. AFTER THIS EPIDEMIC THIS WILL BE THE 4TH MULTIFUNCTION SWITCH THAT I KNOW OF INSTALLED ON THIS CAR. HOW IN THE WORLD HAS THIS PART NOT BEEN RECALLED YET. PLEASE DO SOMETHING!
I HAD PURCHESED A USED 2003 PT CRUISER AND ON THE HWY HOME SHORT TIME LATER I HEARD CLUNKING SOUND THREE TIMES FIRST WHEN MERGING ONTO HWY FROM CAR DEALERSHIP. FUTHERMORE, ABOUT 10 MIN INTO MY HWY DRIVE HOME I BECAME FRIGHTEND WHEN MY CAR ENDED UP HAVING A MIND IF ITS OWN AND STARED GOING TO THE LEFT SO I TRIED TO TURN STEARING WHEEL TOWARDS RIGHT AND I WAS UNABLE TO CORRECT IT FOR FEW SECONDS AND ENDED ON THE OTHERIDE OF WHITE LINE JUST ABOUT OFF HWY AND INTO GRAVEL BUT AT THAT POINT I SEENED TO REGAIN CONTROL OF MY CAR STEARING AND PROCEEDING BACK BETEEEN YELLOW AND WHITE LINE ON THE HWY, FOLLOWING WAS ANOTHER INCIDENT WAS WHEN I CAME TO COMPLETE STOP FOLLOWING WITH LEFT TURN (STARTED TO MAKE A CLUNKING SOUND EVEN LOUDER).DURNING MY ROUTE I MADE A RIGHT TURN THE SOUND AGAIN. I ENDED UP TAKING IT TO A DEALERSHIP TO TAKE A LOOK AT . THE MECHANIC SAID HE KNEW AT ONE POINT THEY HAD A SAFTY RECALL ON THE SUSPENSION FOR PT CRUSIERS BECAUSE THEY COULD CAUSE INJURY WITH MOTOR VEHICLE ACCIDENTS DUE TO LOSS OF CONTROL AS A RESULT OF LOWER CONTOL ARM /SWAY BAR / AND BAD BALL JOINTS WHICH I PERSONALLY PROB EXPERICEND ON MY WAY HOME FOLLOWING MY PURCHESE OF THE CAR. THE MECHANIC I SPOKE TO CHECKED MY VIN NUMBER AND IT DID NOT HAVE A RECALL ON IT HOWEVER THERE WAS RECALLS FOR A SET AMOUNT AND THAT MINE WASNT ONE OF THEM BUT SHOUKD HAVE BEEN AND THAT I SHOULD INFORM " NHTSA "ABOUT MY SITUATION BECAUSE THERE COULD BE OTHERS EXPERIENCING SAME SITUATION DUE TO MALFUNCTIONING PARTS BECAUSE A MALFUCTION CAN HAPPEN TO EVEN AFTER MARKET PARTS CAN LEAD TO DEADLY ACCIDENTS EVEN DEATH BECAUSE OF LOSS OF CONTROL. I STRONGLY AGREE WITH MECHANIC THAT THE RECALL SHOULD BE UPDATED EVEN ON THE AFTER MARKET PARTS FOR THE SUSPENION SUCH AS CONTROL ARM AND CALLED FOR EVERY 2003 PT CRUSIER GT BECAUSE OF LOSS OF CONTROL THAT ALMOST CAUSED ME TO BE IN ACCIDENT EVEN COULD OF BEEN FATAL. THANK YOU
TL* THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STARTED TO JERK AND STALLED WITHOUT WARNING WHILE IN TRAFFIC. THE CONTACT RESTARTED THE VEHICLE AND WAS ABLE TO RESUME DRIVING. THE FAILURE RECURRED TWICE. WHEN THE CONTACT LOOKED UNDER THE HOOD, SHE NOTICED FUEL AROUND THE ENGINE AND THE AREA WHERE THE POWER STEERING FLUID WAS LOCATED, WHICH CAUSED A FUEL ODOR TO EMIT THROUGH THE AIR CONDITIONER BLOWER. THE CONTACT ALSO NOTICED THAT THE REAR OF THE VEHICLE WAS LEAKING FUEL, WHICH CAME FROM THE FUEL LINE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 138,528.
THE MULTIFUNCTION SWITCH HAD TO BE REPLACED OR ELSE THE FOG LIGHTS REMAIN ON AND DRAIN THE BATTERY.
Showing 15 of 257 complaints