Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2017 Ford Explorer.
| Overall Rating | |
| Frontal Crash | |
| Side Crash | |
| Rollover |
| Overall Rating | |
| Frontal Crash |
Component: SEATS
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer vehicles equipped with power front seats. The seat frames may have sharp edges.
Consequence: Occupants my contact the sharp edges when reaching between the power front seat and center console, increasing their risk of injury.
Remedy: Ford will notify owners, and dealers will install protective tape on the exposed inside edge and tab of the power seat frames, free of charge. The recall began November 8, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S29.
Component: SUSPENSION:REAR
Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
Consequence: A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rear suspension toe links, and inspect both rear toe link ball joints, replacing the rear wheel knuckle(s), if necessary, free of charge. The recall began June 26, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S17.
The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed, the A-pillar trim on both sides of the windshield started to detach. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 26V101000 (Suspension); however, the parts to do the recall repairs were not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that parts were not available. The contact was informed that parts had been used to repair other vehicles after the contact had scheduled an appointment. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the failure. The approximate failure mileage was 142,000.
The contact owns a 2017 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 25V347000 (Structure) and 24V031000 (Structure); however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and sent a technician to duct tape the front windshield and front driver’s and passenger’s side door trims. The contact stated that while driving at an undisclosed speed, the A-pillar trim, front driver's and passenger's side door trims, and duct tape had detached. The contact stated that the failure resulted in electrical system failures for the front driver's side door panel, steering wheel control buttons, heated seats, horn, and speedometer. The radio remained in operation after the vehicle was turned off. The second dealer, Fritts Ford (8000 Auto Dr, Riverside, CA 92504); was made aware of the failure but confirmed that parts were not yet available for the recall repairs. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.
The 2017 Ford Explorer has 13 NHTSA recalls and 1629 consumer complaints on file. It received an overall safety rating of 5 out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
| Side Crash |
| Rollover |
Component: WHEELS:HUB
Ford Motor Company (Ford) is recalling certain Wheel Hub Bearing assemblies, part number HB5Z-1104-C, incorrectly listed as being for installation on the rear axles of 2011-2017 Ford Explorer 4X2 vehicles. These bearings assemblies were manufactured without a self retention feature, possibly resulting in the separation of the wheel or wheel end.
Consequence: A loss of the wheel or wheel end can increase the risk of a crash.
Remedy: Ford will notify the distributors of the hubs specifying that they are to only be used on drive axles. It is believed that none of the hubs were purchased from Ford dealers for the incorrect application. Owners may contact Ford customer service at 1-866-436-7332.
Component: STEERING
Ford Motor Company (Ford) is recalling certain 2017 Explorer, Taurus and Police Interceptor Utility and Sedan vehicles. The steering gear heat shield fasteners may corrode, allowing the heat shield to detach.
Consequence: If the heat shield detaches, the steering gear may overheat, increasing the steering effort required by the driver, especially at lower speeds, and increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers to inspect and replace the heat shield fasteners as needed, free of charge. The recall began on September 13, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S23.
Component: SEATS:FRONT ASSEMBLY:RECLINER
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."
Consequence: If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.
Component: ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
Ford Motor Company (Ford) is recalling certain model year 2016 Ford Taurus, 2016-2017 Ford Flex, Lincoln MKT, 2017 Ford Explorer and Ford Explorer Police Interceptor Utility vehicles equipped with 3.5L GTDI engines. Improperly brazed turbocharger oil supply tubes may leak oil on engine components.
Consequence: An oil leak, in the presence of an ignition source, increases the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect, and if necessary, replace the turbocharger oil supply tubes, free of charge. The recall began on January 31, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S46.
Component: STRUCTURE:BODY
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021. Owner notification letters (remedy available) were mailed on October 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S22.
Component: SUSPENSION:REAR
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or ever registered, in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. Exposure to road salt can cause the cross-axis ball joint to corrode and seize, resulting in a fracture of the outboard section of the rear suspension toe link.
Consequence: A rear toe-link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will inspect and replace as necessary, the cross-axis ball joint (CABJ) knuckle, and replace the rear suspension toe links, free of charge. This recall is an expansion of previous NHTSA recall numbers 16V-245, 19V-435, and 20V-675. Certain vehicles previously repaired will need to return for the new remedy. An interim notification letter notifying owners of the safety risk were mailed on September 10, 2021. Owner notification letters were mailed on March 16, 2022. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 21S32.
Component: SUSPENSION:REAR
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin that were previously repaired under a prior recall numbers 16V-245 or 19V-435. The outboard section of a rear suspension toe link may fracture.
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the cross-axis ball joint (CABJ) knuckle attached to the rear suspension toe link and replace it as necessary, free of charge. The recall began November 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S62.
Component: STRUCTURE:BODY:ROOF AND PILLARS
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Consequence: A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. Owner notification letters were mailed on July 18, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Component: STRUCTURE:BODY
Ford Motor Company (Ford) is recalling certain 2016-2017 Explorer vehicles. The driver and front passenger B-Pillar door trim may detach while driving.
Consequence: Door trim that detaches while driving can create a road hazard, increasing the risk of a crash.
Remedy: The remedy is currently under development. Interim letters, notifying owners of the safety risk, were mailed June 5, 2025. A second notice will be sent once the final remedy is available, anticipated November 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S53.
Component: EQUIPMENT:ELECTRICAL:ENGINE BLOCK HEATER
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Component: SUSPENSION:REAR
Ford Motor Company (Ford) is recalling certain 2017-2019 Explorer vehicles. The rear suspension toe links may fracture.
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the toe links, free of charge. Owner notification letters were mailed on March 16, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S08. This recall is an expansion of previous NHTSA recall number 21V537. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 25, 2026.
The contact owns a 2017 Ford Explorer. The contact stated that while driving 60 MPH on the highway, the vehicle hesitated and stalled. No warning light was illuminated. An independent mechanic was contacted. The vehicle was taken to an independent mechanic where it was diagnosed, and it was determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 176,000.
A and b trim pillar pieces are loose and I just lost one going down the interstate. It is also causing my car to leak when it rains. Recall was issued over a year ago and still no parts available to fix it.
The contact owns a 2017 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure); however, the parts to do the recall repairs were not yet available. The contact stated that the exterior A-pillar trims and trims surrounding the windshield were fractured and partially detached. The dealer was contacted and informed that the recall remedy was not yet available. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000.
Filing a complaint as the nhtsa.gov website suggests: "If the manufacturer has failed or is unable to remedy this safety recall for your vehicle in a timely manner ... file an online complaint with NHTSA" It has been over 27 months and I have contacted my dealership numerous times. The local Ford dealership told me that there is no estimated resolution time from Ford, and it will probably never be addressed. I don't understand how it is acceptable for Ford to ignore this issue.
The contact owns a 2017 Ford Explorer. The contact stated that the clips for the B-pillar trims on both sides of the vehicle were fractured, and the B-pillar trims were hanging off the vehicle. The contact then received notification of NHTSA Campaign Number: 25V347000 (Structure); however, the part to do the recall repair was not yet available. The dealer inspected the vehicle and confirmed the failure; however, the contact was reminded that parts were still unavailable to repair the vehicle. The manufacturer was not made aware of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was not repaired. The failure mileage was approximately 40,000.
The trim on both A pillar and B pillar are coming off. When I spoke with Ford about a year ago they informed me of one recall with another coming. One of the trip pieces broke off in an automatic car wash. I was able to go back and get it, but have cut my hand on door multiple times as this is the driver's door with keypad. I have called our local ford and they continue to say there is a recall but no parts available. THIS is very frustrating as now there are two more pieces of trim coming off that could fly off while driving. I want this remedied as this is to be the vehicle my son was planning to take road test in but unsure that this will even be safe. I even wrote a letter to Ford back in March and inquired on this fix and was told to contact dealership. I just spoke with dealership, again who says they can't get the parts for recall.
Coolant keeps going low. No visible leaking spots. Been to 2 mechanic's. Both said Ford defective engine block. Coolant leaking into cylinder 1. Recommended engine replacement. Check engine light. Verified 300 # codes. Misfire. Foul and rough start ups. Been on 4 or 5 months.
The contact owns a 2017 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The contact stated that the A-pillar trim was detaching from the windshield on the passenger’s and driver's side. The dealer was contacted, and it was confirmed that there were no repairs available. A mobile mechanic arrived at the residence and placed tape around the A-pillar trim. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The manufacturer informed the contact that the A-pillar trims were on back order. The failure mileage was approximately 60,000.
My 2017 Ford Explorer suddenly started vibrating intensely whenever I am at a stop or start slowing down. Episodes of hesitation when attempting to take off from a start with significant rpm surges. I am told I need to have my torque converter replaced. My vehicle has 84,697 miles on it, and was bought brand new from a dealer. I already had to have a new engine a month ago. This level of multiple engine and powertrain failures puts consumers and other drivers at risk for harm on the roadway. Not to mention the economic and employment impacts it has on the vehicle owners.
I am reporting a serious safety concern with my 2017 Ford Explorer. The vehicle currently has approximately 93,752 miles and has become increasingly unreliable and unsafe to operate. On April 9, 2026, while my wife was driving home from work, the vehicle overheated, creating a dangerous situation and risk of sudden breakdown. This is especially concerning as the vehicle is used to transport children. Recently, after taking the vehicle in for an oil change, I was informed of multiple additional problems (three separate issues) affecting the vehicle. In addition, the check engine light remains on continuously, even after attempted repairs, indicating unresolved underlying problems. I have also previously attempted to have a recall repair completed, but was told that the necessary part was unavailable and that I would be contacted when it became available. Months later, I have still not been contacted, and the recall issue remains unresolved. Based on my experience and publicly documented issues, this appears consistent with known defects associated with this model, including reported water pump failures leading to engine overheating, rear suspension issues affecting control, and concerns regarding exhaust fumes entering the cabin. This is not normal wear and tear, but a potential safety-related defect. It is a serious concern that known recalls and defects cannot be repaired due to lack of available parts, leaving the vehicle in an unsafe condition. I am also concerned about the risk of continuing to operate this vehicle and potentially causing an accident that could injure myself, my family, or others on the road. This risk is heightened by the lack of timely communication and resolution regarding known defects and recalls. I am requesting investigation into these issues to prevent harm to drivers and passengers
Vehicle experienced white exhaust smoke due to oil entering the exhaust system, caused by turbocharger failure. This led to contamination and failure of all O2 sensors, requiring full replacement, along with replacement of both turbochargers. The radiator also failed and had to be replaced. This appears to be a cascading mechanical failure affecting multiple major systems, including the engine, fuel/propulsion system, and electrical components, rather than normal wear and tear. The failure rendered the vehicle inoperable, leaving me without transportation during a period of financial hardship. The severity and extent of repairs raise concern about a potential broader defect. This also created a safety concern due to excessive exhaust smoke and reduced vehicle reliability while in operation.
No impact shattering of rear window. I entered the car and closed the driver’s side door when I heard the window shatter.
The rear toe link arm is not adjustable, so I can't get it aligned. It has caused a clunking noise when I turn and everytime I align my front end, it does not last.
Showing 15 of 1629 complaints