Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2004 Ford Focus.
| Trim | City | Hwy | Combined | Annual fuel $ |
|---|---|---|---|---|
| 2.0L 4 cyl Automatic 4-spd | 23 | 30 | 25 | $2,400 |
| 2.0L 4 cyl Automatic 4-spd | 22 | 28 | 24 | $2,500 |
| 2.3L 4 cyl Automatic 4-spd | 21 | 28 | 24 | $2,500 |
| 2.0L 4 cyl Manual 5-spd | 24 | 32 | 27 | $2,200 |
| 2.0L 4 cyl Manual 5-spd | 22 | 30 | 25 | $2,400 |
| 2.3L 4 cyl Manual 5-spd | 22 | 30 | 25 | $2,400 |
| 2.0L 4 cyl Manual 6-spd | 18 | 26 | 21 | $3,300 |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: EQUIPMENT
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
Consequence: IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy: RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Component: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
The contact owns a 2004 Ford Focus. The contact stated while driving on several occasions at various speeds, the check engine warning light illuminated, and the vehicle jerked abnormally. There were three clicks before the vehicle stalled. The vehicle was restarted after approximately 10 minutes. The contact stated that on one occasion while driving at an undisclosed speed, the vehicle stalled nearby train tracks. The contact waited for 10 minutes, restarted the vehicle, and drove the vehicle to safety. The vehicle was then towed to an independent mechanic where a handheld diagnostic test indicated that the PCV valve needed to be replaced. The vehicle was then taken to an independent mechanic where it was diagnosed that an ignition coil needed to be replaced. The vehicle was repaired, but the failure reoccurred approximately a month later. The vehicle was taken to the same independent mechanic where it was diagnosed that the fuel relay fuse needed to be replaced. The vehicle was repaired, but the failure reoccurred approximately three weeks later. The manufacturer was not notified of the failure. The failure mileage was approximately 200,010.
As I was stopped at red light it stalled as I drove thru. So I pulled over. Got out to open hood. It was smoking.struggled to open hood. Ran around to get towel to smother the fire. But it was too far gone. Man told me just leave it. It was total loss.
The 2004 Ford Focus has 6 NHTSA recalls and 387 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Component: EXTERIOR LIGHTING:HEADLIGHTS
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence: WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Component: EXTERIOR LIGHTING:HEADLIGHTS
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Component: FUEL SYSTEM, GASOLINE
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
Consequence: FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Component: EXTERIOR LIGHTING
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
2004 ford focus started bucking a few years ago, on occasions only. For months there was no problem and than it would buck. If I shut off the engine and waited a few minutes and started it, it would drive without bucking. Recently, it stalled while driving. Fortunately, I was on a country road and could pull over to safety. Now, on occasion, it wont start. Locks in park. After a while, I can get it out of park and start it. I do not drive it on highways since I am fearful of it shutting off. I have been to three garages for service and they cannot figure it out. I even wrote to the corporate office to ask them to let me know what the problem is. On line many people with 2004 ford focus have the same problem. It isnt just my car. Corporate office answered my letter requesting the vin number on which I gave them. After that, I did not hear from them again. I would think that they would have followed through on this since I told them that it has happened to others with the same vehicle. It stalled again a few days ago as I drove in my driveway. Everytime I try to start it, I hear the clicking sound. I go out once in a while to see if it will start. Sometimes, while in park, it wont start. Another time checking it our, it will start. But, I am not driving it anywhere. I am having it towed to another garage to see if they can figure it out. This car has less than 60,000 miles on it and everything else is good. I have spent a lot of money trying to get this resolved. It has been on diagnostic machines and it doesnt show anything. All I wanted from the corporate office was an engineer to let me know how to fix it. They must have heard the complaints since there are many. A recall wont do me any good since I will be having it looked at again this week. I am doing this for others who have the same problem. However, I would like to know exactly what has caused this.
I was coming home one night, in my 2004 Ford focus, when another driver comes speeding up behind me. He then proceeds to pass me during a corner, cutting me off. I hit the brakes and lost control. Ended up rolling my vehicle with my 8 month old daughter and i. Back window exploded, and not a single air bags had deployed when I got into my accident.
rear passenger door wont latch shut.Door flies open when making turns
IN JANUARY, I WAS INVOLVED IN A TRAFFIC CRASH. I APPLIED THE BREAKS TO MY VEHICLE (GIVING PLENTY OF TIME TO COME TO A STOP AND ONLY TRAVELING 20 MPH ) BUT THE VEHICLE DID NOT COME TO A COMPLETE STOP. AS A RESULT, I HIT A VEHICLE IN FRONT OF ME. I DO NOT KNOW WHAT THE VEHICLE WOULD NOT STOP. IT WAS AS IF THE BREAKS WERE NOT WORKING CORRECTLY.
TL* THE CONTACT OWNS A 2004 FORD FOCUS. WHILE DRIVING VARIOUS SPEEDS, A LOUD NOISE WAS DETECTED FROM THE FRONT OF THE VEHICLE AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE CONTACT ALSO MENTIONED THAT THE KEY OVERHEATED IN THE IGNITION SWITCH AND THE VEHICLE HESITATED TO DRIVE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE CONTACT FURTHER MENTIONED THAT THE VEHICLE'S FUEL CONSUMPTION WAS HIGHER THAN NORMAL. THE CONTACT ALSO MENTIONED THAT BOTH PASSENGER DOORS WERE INOPERABLE. THE CONTACT MENTIONED THAT THE DRIVER'S SIDE DOOR NEEDED EXTRA STRENGTH TO OPEN AND THE REAR PASSENGER DOOR WAS STUCK AND WOULD NOT OPEN. THE VEHICLE WAS TAKEN TO MULTIPLE UNKNOWN DEALERS WHERE THE CONTACT WAS INFORMED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED AND THE ENGINE VALVE WAS STUCK. THE CAUSE OF THE OTHER FAILURES WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 250,000.
MY BATTERY LIGHT SEEMS TO FLASH WHEN THE CAR IS OFF. CAR HAS STALLED SEVERAL TIMES WHILE DRIVING TRY TO ACCELERATE OVER 50 MILES AN HOUR CAR WILL SHUT OFF. BACK HATCH ON WAGON SEEMS TO RELEASE ITSELF WHILE DRIVING WELL UNLOCK AUTOMATICALLY. HAVE REPLACED THREE THERMOSTAT AND THERMOSTAT HOUSING DUE TO OVERHEATING CAR WILL NOT TELL ME IS OVERHEATING IT WILL BOIL IN THE OVERFLOW RETURN TANK PRESSURIZE AND SHOOT THE CAP OFF?...
TL* THE CONTACT OWNS A 2004 FORD FOCUS. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE SAME FAILURES LISTED IN NHTSA CAMPAIGN NUMBER: 06E056000 (FUEL SYSTEM, GASOLINE) AND NHTSA CAMPAIGN NUMBER: 05V030000 (LATCHES/LOCKS/LINKAGES). SHE STATED THAT DUE TO POOR DESIGN, THE QUICK CONNECTORS WOULD NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR WAS FULLY ATTACHED. THE CONTACT ALSO STATED THAT SHE WAS UNABLE TO OPEN THE FRONT DRIVER'S SIDE AND BOTH REAR DOORS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS UNKNOWN.
RECENTLY MY VEHICLE STEREO HAS BEEN MESSING UP. IT SOMETIMES SMELL A LITTLE BURNT. IT IS THE PASSENGER DOOR SPEAKER. IT SOUNDS AS IF IT'S A SHORTAGE INSIDE OF IT. SOMETIMES THE RADIO DASH FADES OUT. THE CAR HAS HESITATES SOMETIMES TO START. ONCE THE AC IS ON THE CAR STARTS RUNNING REALLY ROUGH AND YOU HEAR A KIND OF CLICK IS HARD TO EXPLAIN BUT I KNOW IT'S NOT NORMAL. AT SOMETIMES I AM UNABLE TO RUN THE AC MY WHOLE TRIP. MY ENGINE LIGHT HAS RECENTLY CAME ON I DID REPLACE THE COIL PACKS. ENGINE LIGHT IS STILL ON.
"TAKATA RECALL" TRUNK LID POPS WHEN BRAKES ARE APPLIED. I'M AFRAID THAT IF I HIT A BUMP IN THE ROAD THE LID WILL FLY UP. ALSO IF I POP THE LID WITH KEY FOB BREAK LIGHTS COME ON.
TL* THE CONTACT OWNED A 2004 FORD FOCUS. WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE HESITATED AND STALLED. ALSO, THE OXYGEN SENSOR, MASS AIR FLOW SENSOR, AND THROTTLE BODY SENSOR WARNING INDICATORS ILLUMINATED. SINCE 2016, THE CONTACT ALSO STATED THAT THE FAILURE ONLY OCCURRED WHEN THE VEHICLE WAS PARKED ON AN INCLINE, FACING UPWARDS. THE CONTACT HAD THE VEHICLE DIAGNOSED BY A SCHOOL TEACHER WHO WAS A CERTIFIED MECHANIC. IT WAS DETERMINED THAT THE AIR INTAKE WAS LOCATED IN THE FRONT OF THE VEHICLE AND WATER ENTERED, WHICH DAMAGED THE SENSORS.T HE AIR INTAKE NEEDS TO BE POINTED DOWN TO PREVENT WATER FROM COMING IN. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 180,000. THE VIN IS INVALID. *TT*JB
WHEN PUTTING THE KEY IN THE IGNITION THE KEY WILL NOT TURN AND START THE CAR. IT WILL NOT START AFTER PULLING THE KEY OUT OF THE IGNITION. I AM PREGNANT EXPECTING A BABY. THIS IS A SAFETY HAZARD FOR ME AND MY BABY. IF I GO INTO LABOR AND NEED TO LEAVE TO THE HOSPITAL I CANNOT RISK THE CAR WILL NOT START BECAUSE THE KEY WON'T TURN THE IGNITION ON.
TL* THE CONTACT OWNS A 2004 FORD FOCUS. THE CONTACT STATED THAT THE STEERING COLUMN JAMMED WITHOUT WARNING. THE DEALER (DAY FORD, 3696 WILLIAM PENN HWY, MONROEVILLE, PA) AND MANUFACTURER WERE CONTACTED, BUT DID NOT ASSIST BECAUSE THE VIN WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000.
MY VEHICLE INSTRUMENT CLUSTER FAILED CAUSING ALTERNATOR TO DIE AND FALSE READINGS ON THE DASH WITH MULTIPLE ALERTS SUCH AS BATTERY, AIRBAG , OIL AND INCORRECT SPEED DIAL. THE VEHICLE INSTRUMENT FAILED AT 30,000 MILES AND IF YOU SEARCH IT IS A VERY COMMON ISSUE WITH THE FORD FOCUS VEHICLE'S. THE VEHICLE STALED AND DIED WHILE BEING DROVE IN TOWN AND THANK GOD IT DID NOT HAPPEN WHILE ON THE HIGHWAY.
Showing 15 of 387 complaints