Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 1996 Ford Thunderbird.
| Trim | City | Hwy | Combined | Annual fuel $ |
|---|---|---|---|---|
| 3.8L 6 cyl Automatic 4-spd | 17 | 24 | 19 | $3,150 |
| 4.6L 8 cyl Automatic 4-spd | 15 | 23 | 18 | $3,300 |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: EXTERIOR LIGHTING
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Component: EXTERIOR LIGHTING
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy: AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
WHEN DRIVING THE AIR BAG LIGHT BEGAN BLINKING THE HORN AND CRUISE CONTROL SWITCHESYSTEM STOPPED WORKING IN MOTION FAILURE OF THE CLOCK SPRING
TL* THE CONTACT OWNS A 1996 FORD THUNDERBIRD. THE CONTACT WAS DRIVING 30 MPH WHEN HE NOTICED AN ABNORMALLY STRONG COOLANT ODOR. THE CONTACT THEN INSPECTED THE VEHICLE AND FOUND THAT THE ANTIFREEZE INTAKE MANIFOLD HAD FAILED. THE INTACT MANIFOLD WAS CRACKED AND CAUSING ANTIFREEZE TO SPILL. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO BE DIAGNOSED OR REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 60,000.
TL*THE CONTACT OWNS A 1996 FORD THUNDERBIRD. WHILE DRIVING APPROXIMATELY 25 MPH WITH THE AIR CONDITIONER ACTIVATED THE FAN BLOWER STOPPED FUNCTIONING. THE CONTACT STATED THE FAILURE ALSO OCCURRED WHEN THE HEAT OR DEFROSTER WAS ACTIVATED. THE FUNCTIONS WOULD ALSO OPERATE ERRATICALLY CAUSING THE FAN BLOWER TO GO FROM HIGH TO LOW ON ITS OWN. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND CONFIRMED THAT NHTSA RECALL CAMPAIGN ID NUMBER: 96V007000 (EQUIPMENT:ELECTRICAL:AIR CONDITIONER) WAS RELATED BUT THE VIN WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE 123,100.
The 1996 Ford Thunderbird has 4 NHTSA recalls and 276 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.
Component: EQUIPMENT:APPLIANCE:AIR CONDITIONER
UNDER CERTAIN CONDITIONS, THE CLIMATE CONTROL BLOWER DOES NOT OPERATE AS INTENDED. THE BLOWER COULD (1) STICK ON "HIGH;" (2) OPERATE ERRATICALLY WITH BLOWER OUTPUT VARYING BETWEEN NO BLOWER AND MAXIMUM BLOWER; OR (3) NOT OPERATE AT ALL DUE TO MALFUNCTION OF THE TEMPERATURE CONTROL MODULE.
Consequence: BLOWER MALFUNCTIONS LIMITING OR STOPPING OUTPUT CAN ADVERSELY AFFECT WINDSHIELD DEFROSTING AND DEFOGGING PERFORMANCE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE SEMI-AUTOMATIC TEMPERATURE CONTROL MODULES WITH MODULES CONTAINING REVISED SOFTWARE.
FIRST MY ENGINE SEEMED TO OVERHEAT A BIT THEN EVERY ONCE IN A WHILE IT WOULD SOUND LIKE THE ENGINE WAS GRINDING ON SOMETHING AND WOULDN'T STOP.. SOUNDED LIKE A BUNCH OF CHAINS IN MY HOOD. BUT THEN ON OCCASIONS THE STUPID THING WOULDN'T SHUT OFF WHEN IT WAS MAKING THE CHAIN SOUND, EVEN WITH MY KEY OUT. IT JUST HAPPENED AGAIN AND NOW THE THING SMELLS LIKE SOMETHING IS BURNING AND I HAVE NO POWER WHAT SO EVER IN MY VEHICLE. BEFORE WHEN IT FINALLY SHUT OFF IT SOUNDED LIKE IT WAS ABOUT TO SPARK. THEN IT WAS MAKING A CLICKING NOISE THAT WASN'T COOL. *TR
OPENING DOORS FROM THE INSIDE, LITTLE BY LITTLE, BOTH DOORS FAILED TO OPEN FROM THE INSIDE, HAD TO LEAVE WINDOW OR WINDOWS OPEN TO STICK HAND OUT TO OPEN DOOR FROM THE OUTSIDE. FAILURE OF THESE DOORS TO FUNCTION PROPERLY AT SOME POINT IF BATTERY WOULD GIVE OUT WOULD LEAVE US LOCKED IN, BUT FORTUNATELY THAT DID NOT HAPPEN DUE TO US REMEMBERING TO LEAVE AT LEAST ONE WINDOW OPEN. AFTER SOME MINOR REPAIR, FOUND OUT PLASTIC PARTS WORE OUT AND ONLY ONE DOOR CAN BE UNLOCKED FROM THE OUTSIDE. *TR
1996 FORD EXPLORER, 4X4. DRIVING IN DESERT WENT OVER A BUMP A LITTLE FAST, WHICH SET OFF MY AIRBAGS. MY RIDER IS IN THE HOSPITAL FOR BROKEN NOSE, CHEEK AND SOME KIND OF SMOKE INHALATION. MY WINDSHIELD IS BROKEN BECAUSE THE BAG HIT THE MIRROR WHICH THEN HIT THE WINDSHIELD. MY STEERING WHEEL IS DESTROYED, CRUISE CONTROL AND HORNS ARE OUT OF SERVICE. BEFORE I COULD DRIVE THE CAR AGAIN I HAD TO CUT THE AIRBAGS OUT. WHAT THE HELL IS THIS! NO DAMAGE TO THE CAR EXCEPT WHAT THE AIRBAGS DID. I WANT THIS ALL FIXED AT FORD'S EXPENSE. I HAVE HAD THIS CAR 10 YEARS WITH NO PROBLEMS EXCEPT; RECALLED TIRES, STEERING BARS AND BRAKES (ALL RECALL). *TR
MY 1996 MERCURY VILLAGER DEVELOPED A FAILURE IN THE AIR FLOW SENSOR (PART $330) THAT RESULTED IN VEHICLE STALLS, INCLUDING STOPS ON THE HIGHWAY, THAT NEARLY RESULTED IN CRASHES. THE REQUIRED REPAIRS EXCEEDED $500. I KNOW FORD HAS A SIMILAR RECALL OUT NOW FOR THE 1997-2003 (/) MODELS). *TR
DEFECTIVE INTAKE MANIFOLD. FORD REPLACED ONCE, FREE OF CHARGE @ 48,523 MILES. CRACKED AGAIN @ APPX. 95,700 MILES. FORD REFUSED TO REPLACE FREE OF CHARGE. REPLACED ONE DEFECTIVE MANIFOLD WITH ONE THAT WAS JUST AS DEFECTIVE. THERE WAS A CLASS ACTION SUIT ON THIS MANIFOLD, IT WAS SO BAD. *JB
INTAKE (PLASTIC) CRACKS ;LEAVING FAMILY AND I STRANDED ON 30 MILE STRETCH OF HIGHWAY WITH NO HOUSES OR BUSINESS. TOWED TO STATION AND FIXED RECALLED INTAKE. TAXI COST HOME AND BACK 2 DAYS LATER TO RETRIEVE CAR SOON STARTED HAVING HEATER COIL LEAKS AND OVERHEATING;ANTIFREEZE CAUSING HEADACHES. ALMOST $1000.00 TO REPLACE 30 DOLLAR PART(DASH BOARD AND CONSOLE REMOVED AND AIR CONDITION UNIT DISCONNECTED AND RECHARGED) DEALER TOOK COST OF NEXT 2 REPLACEMENT HEATER COILS AND IT STILL NEEDS 4TH;NO HEAT;STILL LEAKS ANTIFREEZE INSIDE CAR. INTAKE MANIFOLD(PLASTIC) CRACKED AGAIN;OVERHEATED AND BURNT ME THIS TIME ALSO CAUSING SERIOUS DAMAGE TO CAR;VERY COSTLY WHICH I GUESS WE THE CONSUMER WILL HAVE TO BEAR. HOW MANY COMPLAINTS DOES IT TAKE? *TR
TIRE ON 2 CASES BLEW THE TREAD AND BELT, THE LATER OF THE TWO INCIDENCES WHICH RESULTED IN A CRASH THAT TOTALED THE VEHICLE, AND RESULTED IN TWO INJURIES TO BOTH THE DRIVER AND THE PASSENGER. BOTH NEEDED TO BE HOSPITALIZED.*AK
TL* - THE CONTACT WANTED TO HAVE REPAIR DONE TO 1996 FORD THUNDERBIRD, HOWEVER SERVICE BULLETIN #97M91, DATED JAN 19, 1998 (NHTSA ITEM NUMBER: 605621) EXPIRED AND FORD CHARGED FOR THE REPAIRS. THE MILEAGE AT THE TIME OF THE FAILURE WAS 80000. THE CONTACT SAID THAT THE SERVICE BULLETIN WAS FOR THE INTAKE MANIFOLD. THE CONTACT WROTE TO FORD. THE REFUSED TO HONOR THE SERVICE BULLETIN. *AK UPDATED 2/6/2007 - *NM
DEFECTIVE INTAKE MANIFOLD ON 1996 FORD THUNDERBIRD. THE CAR ONLY HAS 84,450 MILES ON IT! COST WAS $1002.02 TO REPAIR. WHY IS THE CONSUMER BEING CHARGED FOR THIS COSTLY REPAIR WHEN THIS IS A KNOWN DEFECTIVE PART FROM THE FORD MOTOR COMPANY?*JB
DT*: THE CONTACT STATED, WHILE TRAVELING AT 30 MPH THE BRAKES FAILED WHILE PRESSURE WAS APPLIED TO THE BRAKE PEDAL. THE VEHICLE WAS TOWED TO A SERVICE DEALER, WHERE A LEAK WAS FOUND ON THE DRIVER'S SIDE FRONT HYDRAULIC BRAKE LINE. THE LINE WAS CORRODED TWO INCHES FROM EITHER SIDE OF A CLIP HOLDING THE BRAKE LINE. NO OTHER CORROSION WAS FOUND ON THE REMAINING BRAKE LINES.
DT*: THE CONTACT STATED THAT THE SPEED CONTROL DEACTIVATION SWITCH WAS LEAKING FLUID. THERE IS A NHTSA RECALL ON OTHER FORD VEHICLES. THE VIN WAS NOT INCLUDED IN THE RECALL. WHEN THE VEHICLE WAS TAKEN TO A SERVICE DEALER, THE REPAIR WERE MADE FOR A FEE. ALSO EVERY 25000 MILES, THE OIL PAN GASKET NEEDED TO BE CHANGED DUE A SMALL LEAK. THE MECHANIC WAS UNABLE TO DETERMINE THE CAUSE OF THE PROBLEM. THIRD, THE EXHAUST AND INTAKE MANIFOLDS WERE LEAKING CAUSING A NOXIOUS SMELL INSIDE THE VEHICLE. THE VEHICLE WAS THEN TAKEN TO THE SAME SERVICE DEALER. THE DEALER REPLACED BOTH MANIFOLDS, AND DETERMINED THAT THERE WAS AN OIL LEAK DRIPPING ONTO THE EXHAUST SYSTEM.
Showing 15 of 276 complaints