2014 Hyundai Santa FE Sport

Component: ENGINE AND ENGINE COOLING:ENGINE

Hyundai Motor America (Hyundai) is recalling certain 2013-2014 Sonata and Santa Fe Sport vehicles. Machining errors during the engine manufacturing process may cause premature bearing wear within the engine.

Consequence: Bearing wear may result in the engine seizing, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will inspect the engine, replacing the engine short block, as necessary, free of charge. The recall began June 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 162.

Full recall detail →

Component: SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Hyundai Motor America (Hyundai) is recalling certain 2013-2015 Santa Fe Sport vehicles. Brake fluid may leak inside the Anti-lock Brake System (ABS) module, possibly resulting in an electrical short.

Consequence: An electrical short in the ABS module can increase the risk of an engine compartment fire while parked or driving.

Remedy: Owners are advised to park outside and away from structures as a precaution until the recall repair is complete. Dealers will replace the ABS multi-fuse, and inspect and replace the ABS module, as necessary, free of charge. Owner notification letters were mailed on August 25, 2021. Note: This recall includes all vehicles previously recalled under NHTSA recall number 20V-520. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 205.

Full recall detail →

Component: SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Hyundai Motor America (Hyundai) is recalling certain 2013-2015 Santa Fe Sport vehicles. Brake fluid may leak inside the Anti-lock Brake System (ABS) module, possibly resulting in an electrical short.

Consequence: If the ABS module short circuits, there is an increased risk of an engine compartment fire.

Remedy: Hyundai will notify owners, and dealers will inspect the ABS module and replace it if necessary, free of charge. Owners are advised to park outside as a precaution until the recall repair is complete. The recall began December 22, 2020. Note: This recall has been superseded by NHTSA Recall 21V-303 and all affected vehicles will now be repaired under 21V-303. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 194.

Full recall detail →

Knock sensor p1326 service code engine light on

The contact owns a 2014 Hyundai Santa Fe Sport. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated and blinked intermittently. The contact stopped at a gas station. The contact filled up the fuel tank and checked the coolant reservoir. When the contact restarted the vehicle, there was an abnormal sound coming from the engine. The vehicle failed to accelerate as intended while depressing the accelerator pedal. The vehicle failed to exceed 30 MPH without shaking or vibrating. The check engine warning light remained illuminated. The vehicle was taken to an independent mechanic who diagnosed that the engine had failed and needed to be replaced. The engine coils or the starter sensor and the O2 sensors were replaced before the independent mechanic informed the contact that the engine had failed. The vehicle was not repaired. The vehicle was then taken to the dealer, where it was confirmed that the engine had failed. The contact was informed that the vehicle was under a service warranty and the vehicle would be repaired. The manufacturer was made aware of the failure. However, the manufacturer refused to replace the engine and offered the contact monetary compensation. The vehicle was not repaired. The failure mileage was approximately 167,000.

Engine seized while driving. Recall-covered failure mode. Hyundai denial despite recall. Screenshots showed recall with VIN for engine recall and suddenly removed by Hyundai next day.

I dont know the exact component that's failed, but it is consuming way too much oil, i have to put a quart in just about everytime i drive it. When i took it the dealership to find out if it was leaking, or burning oil, they literally charged me 200 to tell me it was either leaking oil or burning it. I personally think it is burning vs leaking, because there isnt oil in my drive way. I then spoke to some one on their YouTube channel that told me to call and tell them my story and they should help me out. I did that but no one ever contacted me about the complaint. It's smokes from the engine and i feel like its just a matter of time before it blows up or catches fire. Even though I can hear the engine ticking and struggle the check engine light is not on. From what I've seen this is a known issue that they are ignoring, even though MANY people have complained. This engine has already been replaced in 2018, and the new one is going bad prematurely as well.

Gas is purging from the top of the fuel pump

I purchased this vehicle in November 2022. Hyundai and all affiliates were well aware of the engine recall. I was NEVER informed of the recall, if I was, logically I never would have purchased it. This is fraud by Toyota South in Richmond Kentucky. 6 months or so after purchasing, I began noticing the oil loss, without any oil on the ground where I park the vehicle. I researched and found the recall. I fought with the dealership and Hyundai corporate for 4 months before they said they would replace the engine with a new engine, I was told this early November 2023. I received my car back on 11/24/23. I was told the new engine came with a 12,000(?) mile warranty. I am still looking for this paperwork and will have it available soon. Fast forward to September 2025, as I am driving on I75N to Lexington from Berea, my car shudders and a smoke cloud larger than my vehicle appears behind my car. I check my oil and I am down 2 quarts, which I thought was odd considering I had checked it 2-3 weeks prior to this. I checked it in another week, and it is down 2 quarts again!! There is still no leakage, no oil on the ground, immediately I knew it was another recalled engine. Which is beyond comprehension, why would Hyundai replace a recalled engine, with a recalled engine?? So I go to the dealership and am told I have to do the 3 stage consumption test, drive 1000 miles or be down 1.5 quarts and come back. I was back within 2 days, I drove 150(?) miles and was down 1.5 quarts. The dealership and Hyundai determined the oil consumption issue is present, meaning its a recalled engine. Through phone calls with Hyundai I was told it is also remanufactured, but if you recall, I was told it was a NEW engine. Fraud #2. They refuse to fix it. This is the only vehicle in my household, and my means for income. Hyundai is costing me the right to live, the right to work. They are despicable, awful people to work with. The constant threat of fire is very stressful!!

While driving at approximately 70MPH on the highway, my 2014 Hyundai Tucson Limited suddenly locked up with no warning lights, no noise and no prior symptoms. The engine completely seized, causing immediate loss of power. I was barely able to coast off the highway exit to a final stop on the feeder shoulder, in a desolate area. The vehicle has always been properly maintained and is in excellent condition. Upon research, I learned that Hyundai has known of internal engine defects caused by metallic debris left from manufacturing since 2010, which can cause bearing failure and engine seizure. My Tucson's failure matches the same pattern described in Hyundai's Theta II engine recall and warranty extension campaigns. This sudden failure created an extremely dangerous situation at highway speed and possibility of injury while being stranded on an open road. Many owners, myself included, were never properly notified of the risks. I am filing this report because this incident represents a serious safety defect and potential recurrence among similar vehicles that may not yet be covered by recall. I respectfully request that the National Highway Traffic Safety Administration investigate this issue and ensure Hyundai expands its recall and warranty coverage to include affected 2014 Hyundai Tucson Limited vehicles exhibiting this defect that was well-known to the Hyundai Corporation. Date of Incident: October 23,2025 in Houston Texas. Vehicle towed to Hyundai dealer which diagnosed Engine Seized and currently awaiting Warranty Extension Approval (TXXC/TXXI)

The stationary glass that is in front of the panoramic sunroof shattered for no reason. I found that this has happened to many other people's vehicle like mine. In several incidents, the glass chips fell on passengers in the car when they opened the sunroof. I had a glass repair shop look at it. It will cost $400.00 out of pocket and I don't really want to file a claim to insurance. Can you offer any help?

What happened: While driving in Montana on September 21, 2025, the cabin suddenly filled with gasoline fumes and the accelerator pedal stopped responding. After pulling over, flames erupted from under the hood and the vehicle was completely destroyed within minutes. The passenger-side door could not be opened from the inside at first, delaying escape and creating a serious safety risk. No warning lights or messages appeared before or during the fire. (1) While driving, gasoline suddenly filled the cabin and the accelerator pedal stopped responding. Within seconds, the vehicle caught fire. The cause appears related to the fuel system, and possibly the ABS module. The vehicle was completely destroyed but remains available for inspection in a private tow lot. (2) The fire spread extremely quickly. Both occupants were nearly trapped inside when the passenger-side door would not open from the inside, delaying escape. The vehicle burned on the shoulder of a busy highway in Montana, posing danger to us and to surrounding motorists. (3) Not after this fire, but a similar problem occurred in 2023 when gasoline filled the cabin and caused the engine to stall. At that time, Hyundai replaced the engine under warranty. (4) No. The vehicle has not yet been inspected by the manufacturer, police, or insurance. It is secured in a private tow lot and is available for inspection. (5) No. There were no warnings at all before or during the failure. Even as gasoline filled the cabin and the vehicle caught fire, the check engine light stayed off and no alerts appeared. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Owner: [XXX] VIN: [XXX] Vehicle: 2014 Hyundai Santa Fe Sport My daughter purchased this vehicle in April 2025 from a licensed Chrysler dealership. On [XXX], the engine suddenly seized while driving, without warning, and would not restart. This VIN was part of Recall 17V-226 (Hyundai Campaign 162). Dealer records show the recall was closed with inspection only (“engine inspection, oil, dipstick”), not an engine replacement. The failure matches the defect description of the recall (bearing wear from restricted oil flow). Hyundai is refusing to repair it, claiming sludge and “maintenance neglect,” despite my daughter only owning it for 5 months and having an oil change at Hyundai in May 2025. This engine failure proves the prior “inspection” remedy was ineffective. Hyundai is also denying coverage under the lifetime warranty extension (TXXI), which explicitly applies to subsequent owners for bearing failures. This is a serious safety issue. My daughter lost power in traffic, and the vehicle is still unrepaired. This complaint is being submitted on behalf of the registered owner, [XXX] , by her mother [XXX] , who is the primary contact. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My drivers side door opened while driving. The latch wouldn’t allow me to close my door.

While driving on a steep, narrow grade with no safe shoulder, my 2014 Hyundai Santa Fe Sport suddenly lost all forward power. The engine would rev but the vehicle would not accelerate. I was left stranded in traffic, with cars behind me and nowhere safe to pull off, creating an immediate risk of being rear-ended or rolling back into other vehicles. I had to call for a tow to avoid a serious crash. The vehicle was marked as having all recall campaigns completed, including the rod bearing inspection and knock sensor update, which were supposed to protect against catastrophic engine failure. Clearly, those campaigns were not sufficient to prevent the failure I experienced. At the time of failure, the vehicle displayed the check engine light and drivability symptoms consistent with abnormal combustion and potential bearing damage. Hyundai denied lifetime warranty coverage under the Theta II engine settlement without performing the required inspection. Instead, I was left with an estimate for engine-related repairs that exceeded the value of the vehicle, effectively rendering it a total loss. This failure is exactly what Hyundai’s recall notices describe as a risk: sudden engine failure, loss of motive power, and increased risk of crash. The fact that this happened to my vehicle despite “completed” recall campaigns raises serious concerns about whether the defect remains unresolved and whether Hyundai is adequately honoring its recall and settlement obligations. I am requesting that NHTSA investigate whether Hyundai is improperly denying warranty coverage without inspection and whether vehicles that were marked as repaired under these recalls are still at risk of catastrophic engine failure, stalling, and loss of motive power on public roads. The settlement administrator also works for Hyundai is just referring customers back to Hyundai Customer Care. They are not honoring this CLASS ACTION lawsuit and acting in BAD faith and putting lives at risk.