Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2003 Kia RIO.
| Trim | City | Hwy | Combined | Annual fuel $ |
|---|---|---|---|---|
| 1.6L 4 cyl Automatic 4-spd | 22 | 30 | 25 | $2,400 |
| 1.6L 4 cyl Manual 5-spd | 23 | 30 | 26 | $2,300 |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: SEAT BELTS:REAR/OTHER
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." WHEN USED WITH CERTAIN CHILD SEATS, THE AUTOMATIC LOCKING RETRACTOR (ALR) FUNCTION IN THE REAR OUTBOARD SEATBELT ASSEMBLIES MAY DISENGAGE.
Consequence: IF A CHILD SEAT IS NOT PROPERLY SECURED, THERE IS AN INCREASED RISK OF INJURY TO THE SEAT OCCUPANT IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH REAR OUTBOARD SEATBELT ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 15, 2006. OWNERS MAY CONTACT HYUNDAI-KIA AT 1-800-333-4542.
Component: CHILD SEAT
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' CERTAIN CHILD RESTRAINT ANCHORS WILL NOT FULLY LATCH ONTO THE LOWER LATCH ANCHORS LOCATED BETWEEN THE REAR SEAT BACK AND REAR SEAT CUSHION BECAUSE OF INTERFERENCE BETWEEN THE CHILD SEAT ANCHORS AND A METAL WIRE LOCATED IN THE FRAME OF THE REAR SEAT BACK. UNTIL THE RECALL REPAIR IS COMPLETED, FOLLOW THE INSTRUCTIONS PROVIDED BY YOUR CHILD SEATS MANUFACTURER ON HOW TO PROPERLY INSTALL THE CHILD SEAT WITH YOUR VEHICLE'S REAR SAFETY BELTS RATHER THAN USING THE LATCH SYSTEM.
Consequence: IN THE EVENT OF A VEHICLE CRASH, IF THE CHILD SEAT IS NOT PROPERLY INSTALLED, PERSONAL INJURY OR DEATH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE LOWER ANCHORS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 30, 2006. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
TL* THE CONTACT OWNS A 2003 KIA RIO. THE CONTACT STATED THE BRAKE LIGHTS FAILED TO FUNCTION WHILE DEPRESSING THE BRAKE PEDAL. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF FAILURE. THE CONTACT WAS INFORMED THAT THE VIN WAS NOT UNDER RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000.
SEAT BELTS, CAR SEAT RETAINING HOOKS, ECM, AND DISTRIBUTOR ARE RECALLED. CHEYENNE KIA HAD 3 WEEKS BEFORE ORIGINAL APPOINTMENT TO GET THE PARTS. I DELIVERED THE CAR FOR REPAIRS ONLY TO GET A CALL 4 HOURS LATER THAT THEY CANNOT FIND THE PARTS. IT HAS NOW BEEN 6 WEEKS SINCE PICKING UP MY CAR AND THEY CANNOT FIND THE PARTS TO DO THE RECALL REPAIRS. ALL I HAVE BEEN ABLE TO DO IS LEAVE A MESSAGE WITH JENNIFER XT 45960 AT 800 333 4542 CASE # K3094095 KIA CUSTOMER CARE TO FIND OUT WHEN I CAN SAFELY PUT MY KIDS IN THE BACKSEAT OF THE CAR.
WHEN YOU PARK THE CAR, SHUTOFF ENGINE, PULL UP THE SHORT UNLOCK STICK, THEN PULL THE OPEN BUTTON TO OPEN THE DOOR. THAT'S NORMAL PROCEDURE. BUT IF YOU ARE IN HURRY, PULL THE DOOR OPEN BUTTON FIRST AND FORGET PULL THE UNLOCK STICK, YOU CANNOT OPEN DOOR ANYMORE, YOU CANNOT GO BACK AND PULL UP THE UNLOCK STICK TO UNLOCK DOOR ANYMORE. IT WILL KEEP LOCKING THE DOOR BACK WHEN YOU PULL UP THE UNLOCK STICK. YOU HAVE TO FIGHT FOR 15 MIN TO OPEN THE DOOR. DANGEROUS IF IN THE EMERGENCY.
The 2003 Kia RIO has 3 NHTSA recalls and 84 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: FUEL SYSTEM, GASOLINE:DELIVERY
ON CERTAIN PASSENGER VEHICLES, THE FUEL INTAKE NIPPLE OF THE FUEL DISTRIBUTOR IS SUBJECT TO FRACTURE OR CRACKING DURING REMOVAL OF THE QUICK CONNECT COUPLING SECURING THE MAIN FUEL TUBE ASSEMBLY TO THE FUEL INTAKE NIPPLE, OR WHEN FORCE IS ACCIDENTALLY APPLIED TO THE INTAKE NIPPLE DURING THE VEHICLE ASSEMBLY PROCESS OR DURING ENGINE COMPARTMENT REPAIRS.
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL DISTRIBUTOR AND MAIN FUEL TUBE ASSEMBLIES. THE RECALL BEGAN JUNE 18, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.
ALL OF THE BRAKE LIGHTS QUIT WORKING AT THE SAME TIME. DONE A SEARCH TO SEE IF THERE WAS ANY OTHER PROBLEMS LIKE MINE AND FOUND 3 OTHER OWNERS WITH THE SAME PROBLEM. IT HAS BEEN IN A MECHANIC SHOP FOR 2 WEEKS NOW AND I HAVE JUST GOT DONE TALKING WITH HIM THIS MORNING ABOUT IT AND HE SAID THAT HE HAS NOT BEEN ABLE TO PIN POINT THE PROBLEM. I FEEL THAT THIS IS A SAFETY ISSUE THAT NEEDS TO BE DEALT WITH BY KIA. *TR
FRONT, RIGHT BRAKE ROTOR SEPARATED AT THE INBOARD HALF. PIECES NOT FOUND. OUTBOARD HALF REMAINED INTACT, AND IS AVAILABLE FOR STUDY/ANALYSIS. WAS ABLE TO USE BRAKES ALTHOUGH EXTREMELY SPONGY AND DANGER OF RESULTING FIRE FROM SPARKS (METAL-TOMETAL CONTACT). REPLACED ROTOR AND PADS. VEHICLE IS BACK IN SERVICE. PHOTOS OF OLD PADS AND ROTOR ARE AVAILABLE. *TR
GOING OUT TO DINNER, ABOUT 1 MILE AWAY FROM HOME SMELL COMING FROM CAR. TURNED DOWN A SIDE STREET, SMOKE COMING FROM HEAT/AIR ADJUSTMENT AREA ON DASH. STOPPED CAR, FIRE STARTED COMING OUT OF THE AREA WHERE YOU ADJUST THE HEAT/AIR. BEFORE FIRE DEPARTMENT COULD GET THERE THE ENTIRE CAR WAS ON FIRE. THIS WAS A TOTAL LOSS. THANKFULLY WE WERE ABLE TO GET OUT OF THE CAR. I FEAR IT WOULD HAVE BEEN FAR WORSE IF WE HAD BEEN ON THE EXPRESS WAY AT THE TIME. *TR
TL* THE CONTACT OWNS A 2003 KIA RIO. THE CONTACT STATED THAT THE DRIVER SIDE DOOR LOCK FAILED AND COULD NOT BE UNLOCKED FROM THE INTERIOR OR EXTERIOR OF THE VEHICLE. THE CONTACT MENTIONED THAT IN ORDER TO EXIT THE VEHICLE, SHE HAD TO DO SO THROUGH THE FRONT PASSENGER SIDE DOOR. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE DRIVER DOOR SPRING FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THEY DENIED ASSISTANCE WITH THE REPAIR DUE TO THE AGE AND MILEAGE. THE FAILURE AND CURRENT MILEAGE WAS 85,160.
TL* THE CONTACT OWNS A 2003 KIA RIO. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE VEHICLE STARTED SHAKING VIOLENTLY AND THEN CRASHED INTO THE SIDE OF THE RAMP. WHEN THE CONTACT EMERGED FROM THE VEHICLE, SHE NOTICED THE REAR PASSENGER TIRE FRACTURED COMPLETELY FROM THE SUSPENSION SYSTEM. THERE WERE NO INJURIES AND THE POLICE WERE NOTIFIED. A REPORT WAS AVAILABLE IF NEEDED. THE VEHICLE WAS TOWED TO AN AUTO MECHANIC SHOP AND THE INSURANCE COMPANY WAS ALSO NOTIFIED. THE DEALER WAS NOT NOTIFIED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 85,400.
TL* THE CONTACT OWNS A 2003 KIA RIO. THE CONTACT STATED THAT THE DRIVER SIDE DOOR FAILED AND COULD NOT BE OPENED AUTOMATICALLY OR MANUALLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHICH LOCATED THE FAILURE AT THE DOOR ACTUATOR. THE MANUFACTURER WAS CONTACTED BUT DENIED ASSISTANCE WITH THE REPAIR BECAUSE THE WARRANTY WAS EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 35,000.
THE REAR SEATBELTS DON'T LOCK INTO PLACE RIGHT. NORMALLY, WHEN YOU PULL A SEATBELT THE FULL WAY OUT THEN LET IT WIND BACK IN, IT SHOULD HAVE TENSION ON IT. THE SEATBELTS IN THE REAR OF MY VEHICLE DON'T DO THIS. THEY CAN BE PULLED BACK OUT WITHOUT STOPPING. THEY CLIP INTO THE BUCKLES FINE THOUGH. I HAVE 2 CAR SEATS IN THE BACK, SO I NEED THIS FEATURE TO WORK PROPERLY TO SECURE THE CHILD SEATS. *TR
I BOUGHT MY 03 KIA RIO IN 04 AND WITHIN A MO. HAVE HAD PROBLEMS EVER SINCE. I TOOK IT TO THE DEALERSHIP EVERY MONTH FOR THE FIRST 2YRS WHEN IT WAS STILL IN WARRANTY. THERE WAS ALWAYS SOMETHING CONSTANTLY WRONG OR BREAKING. THE TAIL PIPE RATTLED EXTREMELY LOUD TO THE POINT OF SLIGHTLY SHAKING THE CAR, RANDOMLY WHEN I WOULD CAME TO A STOP. IT WAS SO LOUD THAT PEOPLE IN OTHER CARS COULD HEAR IT AND STARE. OF COURSE THE REPAIR SHOPS COULD NEVER FIND THE PROBLEM. I FINALLY GAVE UP EVER HAVING IT FIXED. I'VE PAID 7 TIMES TO HAVE THE AUTO WINDOWS FIXED BUT FINALLY GAVE UP BECAUSE THEY WOULD ONLY WORK ABOUT TWO DAYS BEFORE BRAKING AGAIN. THE CAR ALWAYS HAD ISSUES ACCELERATING AND WOULD STAIN MAKING NOISES SHAKE A BIT THEN AFTER 10 SECONDS MAKE A POP POP NOISE AND FINALLY START MOVING FASTER. WHICH AGAIN COULD NEVER BE FIXED. THE CAR ALSO HAD HORRIBLE SUSPENSION. EVERY LITTLE PUMP MADE THE CAR BOUNCE AND SQUEAK LOUDLY. ALSO COULD NEVER BE FIXED. I THINK I'VE SPENT MORE TIME IN THE SHOP HAVING THE CAR REPAIRED THEN I ACTUALLY DID DRIVING IT. EVERY TIME I BLINKED SOMETHING ELSE WAS BROKEN I REPLACED ALMOST EVER PIECE OF THE CAR; BATTERY TWICE, ALL FOUR TIRES TWICE, HEAD LIGHTS, ETC THOSE ARE JUST THE SMALL THINGS I'VE ALSO HAD THE CAR COMPLETELY BRAKE DOWN ABOUT 6 TIMES WITH MAJOR REPAIRS. NOW MY CAR IS COMPLETELY DEAD 4/17/11 THE TIMING BELT SNAPPED AND DESTROYED THE ENGINE SO I HAVE TO BUY A NEW ENGINE AND TIMING BELT ALL WHICH COST MORE THEN THE CAR ITSELF THE CAR ONLY HAS 80,000 MILES ON IT SO THAT TELLS YOU HOW MUCH I ACTUALLY GOT TO DRIVE IT IN THE LAST 8YRS. I MADE SURE TO CONSTANTLY KEEP UP ON MAINTENANCE AS WELL. I WILL NEVER BUY A KIA AGAIN ITS A WEIGHT OF MY SHOULDERS TO GET RID OF SUCH A PIECE OF [XXX]. KIAS ARE MADE WITH SUCH CHEAP MATERIALS AND MADE SO POORLY THAT EVERYTHING ON THEM BRAKES AND FALLS OFF. PLEASE ANYONE READING THIS DON'T BUY A KIA YOU WILL REGRET IT. I JUST WANT TO SAVE SOMEONE ELSE FROM A NIGHTMARE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
TL*THE CONTACT OWNS A 2003 KIA RIO CINCO. THE CONTACT STATED THAT THE REAR AUTOMATIC SEAT BELT RETRACTOR WAS NOT LOCKING PROPERLY; THEREFORE, THE SAFETY SEAT MIGHT COME LOOSE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED AND A REPORT WAS FILED SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 70,000.
MY BRAKE PROPORTIONING VALVE ON MY 2003 KIA RIO CRACKED. MY MECHANIC SAYS IT SHOULD NEVER CRACK NO MATTER THE TEMPERATURE CLIMATE ETC. HE SAYS HE HAS NEVER SEEN A CRACKED ONE BEFORE AND MY CAR WOULD HAVE NO SIGNS THAT IT WAS BAD. I WOULD GO FROM PERFECT BRAKES TO NO BRAKES. THAT IS PRETTY MUCH WHAT HAPPENED. I WAS LUCKY AND HAD JUST GOT GAS AND LEAVING THE PARKING LOT. THE BRAKES WENT OUT WHILE I DRIVING SLOWLY TO THE STREET. I HAD ENOUGH BREAK TO STOP. MY COMPLAINT IS NOT FOR ME SO MUCH AS SOMEONE ELSE WHO MAY NOT HAVE BEEN SO LUCKY. I FEAR FOR OTHERS. PLEASE CHECK THIS OUT ON FURTHER VEHICLES. *TR
THE SWITCH ASSEMBLY BLOWER (PART # 97251 FD000) CONSTANTLY GOES OUT ON MY 2003 KIA RIO. THE FIRST TIME IT HAPPENED MY CAR CAUGHT ON FIRE. I REPLACED IT. 6 MONTHS LATER IT WENT OUT AGAIN. I REPLACED IT ALONG WITH THE RESISTOR ASSEMBLY (PART# 1K552 61C08). 8 MONTHS LATER, IT WENT OUT AGAIN. THERE IS NOTHING WRONG WITH THE FUSE. THERE IS NOT A SHORT IN THE SYSTEM THAT CAN BE FOUND. I HAVE YET TO REPLACE THE SWITCH ASSEMBLY ANTICIPATING THE COMPANY RECTIFYING THIS. *TR
BACK IN 2006 I PURCHASED A 2003 KIA RIO AND IN AUG 2009 I WAS SENT A LETTER TELLING ME MY REAR SEATBELTS HAD BEEN RECALLED DUE TO MALFUNCTION WHEN CHILDRESTRANT SEATS WERE USED. THE COMPANY KNEW ABOUT THE RECALL IN 2006 ACCORDING TO THE LETTER BUT DIDN'T NOTIFY ME UNTIL 2009, AND I HAVE A 7 YR OLD SON WHO HAS BEEN RIDING IN MY CAR WITH RECALLED SEATBELTS, THIS MADE ME UPSET SINCE THAT'S THE SAFETY OF MY CHILD. THE COMPANY DID REPLACE THE SEATBELTS BUT IT TOOK THEM ANOTHER 3 WEEKS TO GET THE PARTS AFTER ME NOTIFYING THEM ABOUT THE RECALL LETTER. *TR
Showing 15 of 84 complaints