Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2004 Saturn ION.
| Trim | City | Hwy | Combined | Annual fuel $ |
|---|---|---|---|---|
| 2.2L 4 cyl Automatic (variable gear ratios) | 22 | 29 | 24 | $2,500 |
| 2.2L 4 cyl Automatic 5-spd | 20 | 30 | 24 | $2,500 |
| 2.0L 4 cyl Manual 5-spd | 20 | 26 | 23 | $3,000 |
| 2.2L 4 cyl Manual 5-spd | 23 | 32 | 26 | $2,300 |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: ELECTRICAL SYSTEM:IGNITION
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
The car doesn't always want to release the key. I have to stick my finger up in the column to push the little button to release it which is not convenient at all. It seems to do it if the wheels aren't completely straight. But still even with the steering wheel straight, sometimes it wont come out if its on a slight hill. Ive had a new key made and it makes no difference, no check engine light and auto technician said the ignition looks fine. Ive read tons of reports like this on the 2004 saturn ion 2-why isn't this being addressed?
The contact owns a 2004 Saturn Ion. The contact stated that while driving at an undisclosed speed, the vehicle stalled. Additionally, the contact stated that the key was stuck in the ignition. The failure was intermittent. The vehicle was taken to the dealer, who replaced the ignition switch and the ignition lock cylinder; however, the failure recurred. The contact stated that while driving at an undisclosed speed, the vehicle stalled. The contact related the failure to NHTSA Campaign Numbers: 14V047000 (Air Bags, Electrical System) and 14V171000 (Electrical System). The manufacturer was made aware of the failure. The failure mileage was approximately 230,000.
The drivers side windshield wiper linkage failed at the junction of the metal rod and the plastic wiper mount causing the wiper to stop working. And the wiper arms are almost impossible to remove, even with a puller. Obviously this condition is a safety issue, and other GM vehicles have been recalled for the same issue. Why not the 2004 Saturn Ion?
The 2004 Saturn ION has 10 NHTSA recalls and 898 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: STEERING:ELECTRIC POWER ASSIST SYSTEM
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Component: ELECTRICAL SYSTEM:IGNITION:SWITCH
UCI-FRAM Group is recalling certain LS1328 ignition Switches sold as Wells LS1328, Duralast LS1328, Airtex 1S6097, and Carquest 53-27479, and LS1497 Ignition Switches sold as Wells LS1497, Duralast LS1497, Airtex 1S10961, and Carquest 53-27967, for use on various General Motors model and model year vehicles during repair and replacement of the original ignition switch. The weight on the key ring and/or road conditions or some other jarring event may cause the affected ignition switches to move out of the run position, turning off the engine and disabling the air bags.
Consequence: If the ignition switch moves from the run position to accessory, the car would stall and the air bags will not deploy in the event of a crash, increasing the risk of personal injury to the occupants.
Remedy: UCI-FRAM Group has notified its purchasers to quarantine and return all inventory. Any switches already installed in vehicles will be replaced by GM dealers as part of NHTSA recall 14V-047, free of charge. UCI-Fram's purchasers should contact UCI-FRAM Group at 1-800-890-2075. GM vehicle owners requiring additional information on that recall campaign should contact GM at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac) or 1-800-553-6000 (Saturn).
Component: AIR BAGS
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Component: EXTERIOR LIGHTING
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Component: EXTERIOR LIGHTING:TURN SIGNAL
CERTAIN PASSENGER VEHICLES HAVE A CONDITION IN WHICH THE TURN SIGNAL LAMP AND DAYTIME RUNNING LAMP (DRL) ON EITHER FRONT SIDE CAN STOP WORKING BECAUSE OF LOSS OF CONTACT BETWEEN THE BULB AND SOCKET.
Consequence: IF A FRONT TURN SIGNAL LAMP IS INOPERATIVE, OTHERS MAY REACT MORE SLOWLY TO A TURNING VEHICLE AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE DRL/TURN SIGNAL BULB ON BOTH THE LEFT AND RIGHT FRONT SIDE AND INSPECT FOR AND ADD A DRL JUMPER KIT IF NOT PRESENT. THE RECALL BEGAN NOVEMBER 17, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Component: FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP
CERTAIN VEHICLES EQUIPPED WITH SUPERCHARGED 2.0L 4-CYLINDER (LSJ) ENGINE WERE BUILT WITH A FUEL FEED PIPE THAT COULD CRACK AND LEAK FUEL NEAR THE FUEL RAIL. IF FUEL LEAKS FROM THE FUEL FEED PIPE, THERE WOULD BE A NOTICEABLE FUEL ODOR AROUND THE VEHICLE.
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL FEED PIPE ASSEMBLY. OWNER NOTIFICATION BEGAN ON JUNE 9, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Component: VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 118, "POWER-OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS." THE POWER WINDOWS AND/OR SUNROOF MAY BE OPERABLE AFTER THE IGNITION HAS BEEN TURNED TO THE "OFF" POSITION AND THE FRONT PASSENGER DOOR IS OPENED.
Consequence: IF UNSUPERVISED CHILDREN ARE LEFT UNATTENDED IN THE VEHICLE AND OPERATE THE POWER WINDOWS OR SUNROOF, THERE IS AN INCREASED RISK OF INJURY TO THE CHILD.
Remedy: DEALERS WILL UPGRADE THE BODY CONTROL MODULE (BCM) CALIBRATION. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Component: FUEL SYSTEM, GASOLINE
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.2L 4-CYLINDER (L61) ENGINES WERE BUILT WITH A FUEL FILTER THAT COULD CORRODE PREMATURELY ON THE EXTERIOR SURFACE.
Consequence: IF CORROSION ON THE EXTERIOR SURFACE OF THE FUEL FILTER PROGRESSES TO THE POINT OF CREATING A HOLE IN THE SHELL, FUEL DROPLETS COULD FORM AND DROP TO THE GROUND. IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL REPLACE THE FUEL FILTER ASSEMBLY. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Component: STRUCTURE:BODY:BUMPERS
ON CERTAIN PASSENGER VEHICLES, SOME WELDS BETWEEN THE PASSENGER'S SIDE MOTOR RAIL AND THE FRONT BUMPER BRACKET DO NOT MEET ENGINEERING SPECIFICATIONS.
Consequence: LONG TERM DURABILITY OF THE JOINT MAY BE REDUCED AND SEPARATION OF THE BUMPER FROM THE FRAME ON THE PASSENGER'S SIDE OF THE VEHICLE MAY RESULT, INCREASING THE RISK OF A CRASH.
Remedy: ALL VEHICLES ARE STILL IN DEALER'S POSSESSIONS.
The contact owns a 2004 Saturn Ion. The contact stated while driving at various speeds, excessive force was needed to maneuver the steering wheel on several occasions. The power steering assist warning light was illuminated. The contact stated that he replaced the electric power steering motor; however, the failure persisted. The vehicle was not taken to a local dealer or independent mechanic for additional diagnostic test or repair. The manufacturer was not made aware of the failure. The failure mileage was unknown.
My car started getting a strong odor of gas. A fuel pipe leak is causing the odor
Hi I am a kind of new owner of an 04 saturn ion, this is actually the second complaint I've filled out. Last July I had a mechanic friend look at my fuel filter and he had said the fuel line needed to be cut off becuase of how rusted on to the original fuel filter I'd got it with was and I didn't believe him so I replace it myself and when I got it off I had cleaned up the metal fuel line the best I could and put a new filter on. Well now it leaks gas right where the hook up is and very strong fuel smells come from there too, I've gotten numerous comments about how un safe that is to be driving it but I need to have a way to work and then someone had mentioned to check for recalls and I seen on there that this car did have a recall for faulty fuel filter gas lines. If you could get back to me as soon as possible about an inspection if needed or whatever else you'd need on my behalf. Please and thank you for your time
TRIED TAKING FUEL FILTER OFF LAST JULY TOOK A WHOLE WEEKEND OF USING PENATRATING OIL AND FREEZE OFF THEN I FINALLY GOT THE TABS TO COME LOOSE, I THOUGHT MAYBE I MESSED UP THE NEW FILTER OR DIDNT GET ENOUGH RUST OFF THE FUEL LINE AND THAT'S WHAT WAS CAUSING THE STRONG SMELL OF GAS ND POOR PERFORMANCE BUT CHANGED IT AGAIN AND STILL THAT SAME PROBLEM BUT NOW THERES A LEAK. THE CAR WAS ON BACK TIRE RAMPS THE GIRL FUEL FILTER CHANGE THEN THE 2ND ONE WAS DONE WITH A HOIST AND CURRENTLY THIS CAR IS THE ONLY THING I CAN COUNT ON TO MAKE IT TO WORK, THANK YOU FOR YOUR TIME AND CONSIDERATION.
THE FUEL PUMP IS LEAKING, GM REFUSES TO FIX IT BECAUSE THE VIN ISN'T ASSOCIATED WITH THE RECALL, BUT THE SAME YEAR MAKE AND MODEL OF MY CAR SAYS IT HAS A RECALL FOR THE FUEL SYSTEM AND PUMP.
FUEL LEAK ON REAR DRIVER SIDE WHEN THE ENGINE IS RUNNING WHILE CAR IS STATIONARY. IT MAY HAVE HAPPENED BEFORE THE DATE AND MILEAGE STATED BELOW BUT THAT'S WHEN I FIRST NOTICED THE FUEL LEAK.
POWER STEERING STICKS. I TAKE A 55MPH CURVE AND THE STEERING WHEEL DOESN'T COME BACK TO CENTER. IT WANTS TO TAKE ME OFF THE ROADWAY.
TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE VEHICLE LOSS POWER STEERING WITHOUT WARNING. THE CONTACT TURNED OFF AND RESTARTED THE VEHICLE AND THE VEHICLE OPERATED AS INTENDED. ADDITIONALLY, THE WINDOWS ROLLED UP AND DOWN INDEPENDENTLY. THE CONTACT ALSO STATED THERE WAS AN ABNORMAL FUEL OUTSIDE THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED. A DEALER WAS NOT CONTACTED HOWEVER, THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT WAS REFERRED TO THE LOCAL DEALER TO HAVE THE VEHICLE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 172,639.
WE HAVE BEEN HAVING TROUBLE REMOVING THE KEY FROM THE IGNITION THE PAST FEW DAYS. AS I WAS MAKING A LEFT TURN THE STEERING WHEEL LOCKED THEN MADE A LOUD POPPING SOUND. NOW THE STEERING WHEEL JUST SPINS IN A COMPLETE CIRCLE AND DOES NOT TURN THE WHEELS. I WAS IN MOTION IN A PARKING LOT.
WHEN THE KEY IS IN THE OFF POSITION AND REMOVED FROM THE CAR THE LIGHTS ON THE DASH STAY ON. CAR IS PARKED WHEN THIS HAPPENS.
TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT THE POWER STEERING ASSIST FAILED TO FUNCTION AS DESIGNED INTERMITTENTLY WHICH CAUSED DIFFICULTY WHILE ATTEMPTING TO MANEUVER THE VEHICLE. THE VEHICLE WAS TAKEN TO VERA CADILLAC LOCATED AT (300 S UNIVERSITY DR, PEMBROKE PINES, FL 33025, (954) 417-8998) TO BE DIAGNOSED. THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE OR RETRIEVE A FAULT CODE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 244,000.
Showing 15 of 898 complaints