Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 1997 Volvo 850.
| Trim | City | Hwy | Combined | Annual fuel $ |
|---|---|---|---|---|
| 2.3L 5 cyl Automatic 4-spd | 17 | 24 | 19 | $3,650 |
| 2.4L 5 cyl Automatic 4-spd | 18 | 26 | 21 | $3,300 |
| 2.4L 5 cyl Automatic 4-spd | 18 | 24 | 20 | $3,450 |
| 2.4L 5 cyl Manual 5-spd | 18 | 26 | 21 | $3,300 |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
VEHICLE DESCRIPTION: PASSENGER VEHICLES. OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.
Consequence: DRIVER'S COULD EXPERIENCE A LOSS OF VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE HEADLIGHT SWITCH.
Component: FUEL SYSTEM, GASOLINE:STORAGE
ON CERTAIN PASSENGER VEHICLES, AFTER PROLONGED EXPOSURE TO HEAT, THE FUEL TANK MAY SEEP OR LEAK FUEL AT THE POINTS WHERE THE HEAT SHIELD IS ATTACHED.
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: VOLVO WILL INSPECT THE FUEL TANK AND REPLACE IT IF ANY EVIDENCE OF FUEL SEEPAGE OR LEAKAGE IS FOUND. ALL VEHICLES WILL RECEIVE NEW REINFORCEMENT BUSHINGS AT THE HEAT SHIELD ATTACHMENT POINTS TO PREVENT FUTURE LEAKS. THIS RECALL WILL BE CONDUCTED AS A SAFETY RECALL IN THE HOT WEATHER STATES OF ALABAMA, ARKANSAS, ARIZONA, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, AND UTAH, AND AS A SERVICE RECALL IN THE OTHER 33 STATES AND THE DISTRICT OF COLUMBIA. THE RECALL BEGAN ON SEPTEMBER 24, 2004. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
SIMILAR TO NHTSA ID NUMBER: 10365806. WHEN FUEL TANK IS FILLED COMPLETELY, THERE IS A STRONG ODOR OF FUEL OUTSIDE THE VEHICLE AND SOME FUEL ODOR IN THE TRUNK. NO ODOR WHEN TANK IS ONLY PARTIALLY FULL, E.G., 80% FULL. ODOR NOTICED WHEN VEHICLE STATIONARY. NO ODOR IN PASSENGER COMPARTMENT. ISSUE ONGOING FOR ROUGHLY LAST 7 YEARS (NOT SURE). NO DRIPPING FUEL OBSERVED. LEAK MAY BE AT FUEL PUMP QUICK-DISCONNECT FITTINGS. LEAK MAY HAVE STARTED AS A RESULT OF EVAP SYSTEM REPAIR IN LATE 2009--NOT SURE. DEALER CLAIMED TO HAVE FIXED LEAK AT FUEL PUMP FITTINGS IN 2011, BUT ODOR ISSUE PERSISTS IF TANK COMPLETELY FULL. NO CHECK ENGINE LIGHT ISSUES SINCE 2011. I AVOID FILLING TANK COMPLETELY TO AVOID ODOR. IF I INADVERTENTLY FILL TANK COMPLETELY, ODOR RETURNS. "WHEN DID THIS HAPPEN" DATE I ENTERED IS JUST A ROUGH GUESS OF WHEN THE ISSUE STARTED. VEHICLE IS STORED OUTDOORS AND DRIVEN INFREQUENTLY, ~ ONCE PER WEEK AVERAGE. ODOR IS EASILY NOTICEABLE OUTDOORS WHEN TANK IS COMPLETELY FULL.
GENERAL ALTIMAX RT43. I HAD 4 TIRES IN LESS THAN 6 MONTHS AND 6,000 MILES DEVELOP SIDE WALL BUBBLES CAUSED BY TIRE PLAY SEPARATION AND BANDS BREAKING. I TIRE HADE BEEN REPLACED AND IT DEVELOPED A BUBBLE IN LESS THAN A MONTH. NO HARD DRIVING ON THE CAR AND NO POTHOLES OR RAILROAD TRACK IMPACTS. THIS IS A COMMON THREAD AND IT IS TIME FOR THE NHTSA TO INVESTIGATE. I HAVE NOW BOUGHT SIX TIRES IN SIX MONTHS TO REPLACE THE DAMAGED TIRES. I AM STILL WAITING TO HERE IF GENERAL WILL REPLACE ONE UNDER WARRANTY AND HAVE ANOTHER IN THE TRUNK OF MY CAR THAT NEEDS TO BE REPLACED WHILE I DRIVE AROUND ON THE SPARE TIRE. THIS SHOULD NOT HAPPEN UNDER NORMAL USE. PRIOR TO THIS I HAVE DRIVEN APPROXIMATELY 1MILLION MILES AND HAVE NEVER HAD TO REPLACE A TIRE DUE TO SIDE WALL BUBBLES.
The 1997 Volvo 850 has 3 NHTSA recalls and 138 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
ON SOME SEDANS AND STATION WAGONS EQUIPPED WITH SEAT HEATERS, IT IS POSSIBLE THAT EXCESSIVE COMPRESSION OF THE SEAT CUSHION COULD CAUSE DAMAGE TO THE ELECTRICAL WIRING OF THE SEAT HEATER.
Consequence: IF THIS OCCURS, THE DAMAGE COULD RESULT IN A SHORT CIRCUIT THAT COULD CAUSE A FIRE.
Remedy: DEALERS WILL DISCONNECT THE EXISTING WIRES AND INSTALL A NEW ELECTRONIC THERMOSTAT AND CABLE HARNESS. OWNER NOTIFICATION BEGAN ON FEBRUARY 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.
THE TIRE DEALER RECOMMENDED MICHELIN PRIMACY MXV4 AS A REPLACEMENT TIRE FOR MY 1997 VOLVO 850 (NORMALLY ASPIRATED) SEDAN. THE MICHELIN WEBSITE DESCRIBED THIS TIRE AS AN "ACCEPTABLE SUBSTITUTE" FOR THE TIRES SPECIFIED BY VOLVO BECAUSE MICHELIN NO LONGER OFFERS HIGH PERFORMANCE TIRES IN MY SIZE. STOPPING POWER IS MUCH WORSE WITH THESE NEW MICHELIN TIRES. THEY SQUEAL EASILY, EVEN AT VOLVO'S HIGHEST RECOMMENDED AIR PRESSURE (36PSI). I HAD DIFFICULTY STOPPING FROM 50MPH IN AN EMERGENCY, FOR THE FIRST TIME IN MY 17 YEAR OWNERSHIP OF THIS VEHICLE. I BLAME THESE NEW "COMFORT ORIENTED" TIRES. *TR
TL* THE CONTACT OWNS A 1997 VOLVO 850. THE CONTACT STATED WHEN FUEL WAS DISPENSED INTO THE FUEL TANK TO THE FULL CAPACITY LEVEL, SHE WOULD SMELL A STRONG ODOR OF FUEL INSIDE AND OUTSIDE OF THE VEHICLE. IN ADDITION, THERE WOULD BE FUEL LEAKAGE ON THE GROUND UNDERNEATH THE FUEL TANK. THE FUEL WAS DISPENSED TO THREE QUARTERS OF A TANK TO AVOID THE FAILURE. THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 04V368000 (FUEL SYSTEM, GASOLINE:STORAGE). THE VIN WAS NOT INCLUDED IN THE RECALL DEFECT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000.
ODOMETER FAILURE AT UNDER 90,000 MILES. ORIGINAL EQUIPMENT; NOT TAMPERED WITH; VEHICLE NEVER IN AN ACCIDENT. *TR
UNINTENDED ACCELERATION. CAR IN NORMAL DRIVE, JUST STARTS TO ACCELERATE. ALSO SOMETIMES ENGINE RACES WHILE IN PARK OR IDLE FOR NO REASON. OCCURS RANDOMLY, BUT HAS BEEN RECURRING DAILY FOR TWO WEEKS. HAVEN'T TAKEN TO DEALER YET. *TR
IN A PARKING GARAGE I TURNED MY WHEELS TOWARDS THE LEFT TO DRIVE INTO A PARKING SPOT; I GAVE THE CAR A LITTLE GAS WHILE DRIVING OVER A SPEEDBUMP AND SUDDENLY THE CAR ACCELERATED AND SHOT FORWARD AT A HIGH RATE OF SPEED. THANKFULLY THE CAR WENT INTO THAT PARKING SPOT AND HIT THE CEMENT WALL AND STOPPED. I THOUGHT IT WAS A ONE-TIME OCCURRENCE BUT WITH ALL THE REPORTS OF TOYOTA ACCELERATION PROBLEMS, NOW I WONDER IF THIS CAN OCCUR IN ANY CAR AT ANY TIME. I HAVE A 1997 VOLVO STATION WAGON. WITH SPEED BUMPS ON MANY STREETS NEAR SCHOOLS, IF THIS CAN HAPPEN ON ALMOST ANY CAR, THEN THE POTENTIAL FOR MAJOR ACCIDENTS IS UNLIMITED. I WILL ALWAYS KEEP MY FOOT ON THE BRAKE PEDAL WHILE GOING OVER ANY SPEED BUMP FROM NOW ON, AND AM JUST THANKFUL THAT I WAS JUST A COUPLE OF FEET FROM A CEMENT WALL AND HAD ALREADY TURNED MY WHEELS. FOR THOSE REASONS, NO DAMAGE WAS DONE TO EITHER THE WALL, MY CAR OR THE OCCUPANTS. (IN THE MILEAGE AND SPEED INFO. ON THIS FORM I CAN ONLY GUESS AT THE MILEAGE AT THE TIME OF INCIDENT AND THE SPEED AT WHICH THE CAR ACCELERATED.) *TR
ABS MODULE FAILED. LOOKS LIKE MAJOR DEALER REPAIR. THIS IS A MAJOR COMPONENT OF THE VEHICLE AND SHOULD BE TREATED AS SUCH AND NO LONGER TREATED AS AN ACCESSORY ITEM. FOR THESE DEVICES TO BE CONSIDERED AN "ACCESSORY" THEY SHOULD THEN BE MADE AS USER REPLACEABLE WHICH IS NOT THE CASE. THEN AGAIN, IS IT A GOOD IDEA TO HAVE EVERY SUNDAY-MECHANIC REPLACING SUCH A CRITICAL ITEM? I HAVE HAD AN ABS WARNING LIGHT FOR OVER TWO YEARS NOW. DIAGNOSTICS SAY ITS THE ABS ELECTRONICS. I DO NOT HAVE THE BUDGET OR EXPERIENCE TO REPLACE IT. SEVERAL WEBSITES POINT TO FAILING OR DEFECTIVE CAPACITORS ON THE ELECTRONIC MODULE ITSELF. *TR
MY DAUGHTER USED FAMILY CAR, VOLVO 1997, 850 WAGON AND THE ACCELERATOR FAILED WIDE OPEN. SHE NARROWLY MISSED 5 YOUNG CHILDREN PLAYING STREET HOCKEY. CAR IS INOPERABLE AND MUST BE TOWED TO SERVICE STATION FOR EVALUATION AND REPAIR. *TR
TL*THE CONTACT OWNS A 1997 VOLVO 850 WAGON. THE VEHICLE WAS TAKEN TO A SERVICE STATION FOR TIRE REPAIR AND THE FOLLOWING FAILURES WERE DISCOVERED: BOTH REAR BRAKES AND CALIPERS WERE SEIZED AND COMPLETELY INOPERABLE, THE EMERGENCY BRAKE WAS ALSO INOPERABLE, AND BOTH FRONT INNER AND OUTER TIE RODS NEEDED TO BE REPLACED. THE ESTIMATED REPAIR COST WAS $1,230. THE VOLVO DEALER DIAGNOSED THE FOLLOWING FAILURES: BOTH FRONT LOWER CONTROL ARMS AND THE DRIVER SIDE TIE RODS FAILED, AN ALIGNMENT WAS NEEDED, THE FRONT AND REAR BRAKES FAILED, INCLUDING THE ROTOR AND CALIPERS, AND THERE WAS AN EMISSIONS ISSUE AS WELL. THE VEHICLE NEEDS COMPLETE EMISSION REPAIR. THE VEHICLE WAS PURCHASED ON JUNE 21, 2008 AND PASSED INSPECTION ON JUNE 25, 2008. THE FAILURE MILEAGE WAS 127,700.
TL*THE CONTACT OWNS A 1997 VOLVO 850. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE BEGAN TO VIBRATE FOR APPROXIMATELY 5 TO 10 MINUTES. THE TREAD THEN BEGAN TO SEPARATE FROM THE TIRE AND CONTINUOUSLY STRUCK THE FENDER OF THE VEHICLE. THE FENDER, PASSENGER SIDE DOOR, AND ROCKER PANEL WERE DAMAGED. THE CONTACT HAS NOT NOTIFIED THE TIRE MANUFACTURER. THE VIN, PURCHASE DATE, ENGINE SIZE, AND NUMBER OF CYLINDERS WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 240,000.
TL*THE CONTACT OWNS A 1997 VOLVO 850. THE HEADLIGHTS WOULD NOT ILLUMINATE WHEN THE VEHICLE WAS STARTED. THE HEADLIGHTS WOULD ALSO NOT DIM WHEN THE VEHICLE WAS TURNED OFF. THE HEADLIGHT SWITCH WAS DEFECTIVE, BUT IT WAS NEVER USED BY THE CONTACT. WHEN THE SWITCH WAS ENGAGED, THE HIGH BEAMS WOULD MOMENTARILY ILLUMINATE. HER VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 99V235000 (EXTERIOR LIGHTING:HEADLIGHTS:SWITCH). THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 100,000.
1. LOSS OF ACCELERATION AND SOMETIMES STALLING DURING FREEWAY TRANSITION FROM ON RAMP TO FREEWAY AND OR DURING LEFT TURNING AGAINST TRAFFIC. 2. THE CAR FAILED TO ACCELERATE AND THE ACTION OF PUSHING THE ACCELERATOR CAUSED THE TRANSMISSION TO DOWN SHIFT CAUSING THE EXTREME SLOWING AND SOMETIMES STALLING. THE CONSEQUENCES WERE THAT TRAFFIC WAS GOING CONSIDERABLY FASTER AND HAD TO TAKE EVASIVE ACTION TO AVOID HITTING THE SLOWING CAR. 3. TODAY THE MEDIA REPORTED A POTENTIAL RECALL OF VOLVO'S DUE TO THIS PROBLEM AND I BELIEVE IT SHOULD BE EXTENDED TO 1997 MODEL 850 GLT. *JB
DT*: THE CONTACT STATED WHILE DRIVING 35MPH ON A CITY STREET, THE VEHICLE WAS INVOLVED IN A FRONT IMPACT COLLISION AND THE AIRBAGS DID NOT DEPLOY. THE CONTACT WAS WEARING A SEAT BELT, NO INJURIES WERE SUSTAINED. THERE WAS MINOR DAMAGE TO THE VEHICLE. THE POLICE WERE ALERTED, AND A REPORT WAS TAKEN. THE VEHICLE WAS NOT INSPECTED. THE MANUFACTURER WAS NOT ALERTED.
THE TRAC OFF LIGHT COMES ON ON MY 1997 VOLVO 850 GLT TURBO WAGON. APPARENTLY, THE TRAC, NO LONGER WORKS AND I HAVE TO PAY HUNDREDS OF DOLLARS TO GET IT FIXED. THIS SHOULD BE A RECALL AND RELATES DIRECTLY TO A SAFETY CLAIM MADE BY VOLVO. FROM THE LIST SERV THAT I AM ON, APPARENTLY THIS IS A VERY COMMON PROBLEM AMONGST 1996-1998 VOLVOS. *JB
Showing 15 of 138 complaints