Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2007 Volvo S80.
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: SEAT BELTS:FRONT
Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating positions may fatigue over time, causing the seat belt to not secure the occupant in the event of a crash.
Consequence: An unsecured occupant has an increased risk of injury in the event of a crash.
Remedy: Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R10029.
Component: STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
VOLVO IS RECALLING CERTAIN MODEL YEAR 2007 S80 PASSENGER CARS MANUFACTURED FROM MARCH 8, 2006, THROUGH MAY 16, 2007. THE POWER STEERING RESERVOIR RETURN HOSE MAY HAVE BEEN INCORRECTLY ROUTED, WHICH CAN RESULT IN INCREASED PRESSURE IN THE POWER STEERING SYSTEM. THE POWER STEERING RETURN HOSE MAY BURST AT THE STEERING GEAR DUE TO THE INCREASED PRESSURE, RESULTING IN A LOSS OF POWER STEERING FLUID.
Consequence: THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING, INCREASING THE RISK OF A CRASH.
Remedy: VOLVO DEALERS WILL INSPECT THE ROUTING OF THE POWER STEERING RESERVOIR RETURN HOSE AND MAKE REPAIRS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2011. OWNERS MAY CONTACT VOLVO AT 1-201-768-7300.
The contact owns a 2007 Volvo S80. The contact stated that while operating the vehicle during a rainstorm; rainwater leaked into the vehicle from the top section of the driver's side of the windshield, creating a visibility hazard for the driver. The cause of the failure was not determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted regarding the failure. The failure mileage was 150,000.
These generation of Volvo p3 platform cars had a defective windshield seal that was not the best from the factory. Many cars of this generation (S60, S80, XC90, etc) have had the seals break, causing extreme water leakage as mine has had. And the possibility of the windshield falling out. Mine is bad enough that pushing it lightly from the inside to create a significant gap in the window and the frame of the A pillar. There are many forums and reports of this exact problem and Volvo has yet to voluntarily recall these cars. Many people have reported it to many dealers, but all say they cant replace them. This problem definitely puts the driver and other people in the cabin in danger. And no warning lights go off in relation to the problem. I appreciate your consideration.
Warning light on dashboard indicated right front headlamp out. Repair shop removed and replaced original component with new component. Internal inspection of light assembly revealed missing insulation(photos attached) on wiring harness causing a short circuit which also ruined the headlight igniter and control module. Shop stated that this issue is NOT uncommon with Volvo lighting systems. The current concern is the same condition is present in the left(driver) headlight and could cause a short and fire within the headlight assembly. Correspondence with Volvo resulted in no resolution of the issue and lack of concern for the reliability of installed components or possible safety concern for their product.
The 2007 Volvo S80 has 5 NHTSA recalls and 24 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: ELECTRICAL SYSTEM:SOFTWARE
VOLVO IS RECALLING 12,303 MY 2007-2008 S80 AND V70 VEHICLES. THE DIAGNOSTIC SOFTWARE IN THE CENTRAL ELECTRONIC MODULE (CEM) MAY CAUSE A MALFUNCTION OF THE WINDSHIELD WIPER FUNCTIONALITY. IF THIS CONDITION OCCURS, THE WINDSHIELD WIPERS MAY NOT OPERATE WHEN ACTIVATED; OR IN CERTAIN CASES THE WINDSHIELD WIPERS MAY ACTIVATE WHEN NOT SWITCHED ON.
Consequence: OPERATING A MOTOR VEHICLE DURING INCLEMENT WEATHER CONDITIONS WITHOUT FUNCTIONING WINDSHIELD WIPERS CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE CEM AND UPGRADE THE SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON MAY 15, 2009. OWNERS MAY CONTACT VOLVO CUSTOMER CARE CENTER AT 1-800-458-1552, OR CUSTOMERCARE@VOLVOFORLIFE.COM.
Component: EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
Component: TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
VOLVO IS RECALLING CERTAIN MODEL YEAR 2007-2010 S80 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE AND LOADING INFORMATION LABEL AND A PAGE IN THE OWNER'S MANUAL CONTAIN INCORRECT MAXIMUM PERMISSIBLE INFLATION PRESSURE AND THE TIRE PRESSURE MONITORING SYSTEM (TPMS) SOFTWARE HAS AN INCORRECT TRIGGER LEVEL.
Consequence: THESE VEHICLES DO NOT MEET THE REQUIRED SAFETY STANDARDS.
Remedy: DEALERS WILL UPDATE THE VEHICLES WITH A NEW TIRE AND LOADING INFORMATION LABEL, OWNER'S MANUAL LABEL AND TPMS SOFTWARE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT AUGUST 27, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR CUSTOMERCARE@VOLVOFORLIFE.COM .
EXCESSIVE RUST IS FORMING ON MY FRONT SUBFRAME AND IN SOME PLACES HAS RUSTED COMPLETELY THROUGH. SMALL PERFERATIONS WERE NOTICED AT REPAIR FACILITY AND I WAS TOLD THAT IT WILL NEED TO BE REPLACED. IT CANNOT BE WELDED/REPAIRED. THIS IS A KNOWN PROBLEM WITH THE 2007-2010 VOLVO S80 V8 WHICH VOLVO REFUSES TO RECALL AND WILL BE AN EXTREMELY COSTLY REPAIR. IT ALSO MAKES THE CAR UNSAFE TO DRIVE SHOULD THE REPAIR NOT BE MADE.
EXCESSIVE RUST IS FORMING ON MY FRONT SUBFRAME AND IN SOME PLACES HAS RUSTED COMPLETELY THROUGH. I HAVE A SILVER DOLLAR SIZED HOLE THROUGH IT AND IT WILL NEED TO BE REPLACED. THIS IS A KNOWN PROBLEM WITH THE 2007-2010 VOLVO S80 V8 WHICH VOLVO REFUSES TO RECALL AND WILL BE AN EXTREMELY COSTLY REPAIR. IT ALSO MAKES THE CAR UNSAFE TO DRIVE AND I COULD ALSO NOT PASS INSPECTION IN PA FOR THIS KIND OF DAMAGE.
SEVERE SUBFRAME RUST DUE TO EXCESSIVE HEAT FROM THE EXHAUST ON THE V8 MODELS OF THE VOLVO S80S ONLY. DEALER SAID THE EXCESSIVE HEAT WILL MELT THE PAINT OFF, CAUSING RUST TO ATTRACT TO THE SUBFRAME. THE SUBFRAME IS A CRITICAL COMPONENT TO THE CAR, UNFORTUNATELY ALTHOUGH VOLVO HAS SAID THIS IS A COMMON PROBLEM ON THE V8 MODELS, THEY WILL NOT DO ANYTHING TO FIX THE PROBLEM. THIS IS THE ONLY PLACE MY VEHICLE HAS RUST, AND THE CAR IS UNDERCOATED YEARLY.
THIS CAR REALLY HAS A BAD TRANSMISSION PROBLEM AND IT JERKS SOO BAD IT BEEN DOING THAT FOR A LONG TIME
FRONT SUB-FRAME WHICH HOLDS ENGINE/TRANSMISSION/FRONT SUSPENSION HAS SIGNIFICANT EXTERNAL AND INTERNAL CORROSION. ADVANCING CORROSION WILL EFFECT STEERING AND ENGINE MOUNT CAUSING A LOSS OF CONTROL. CAR PARKED WHEN NOTICED, 5/14/2019. BELIEVED TO BE PROBLEM WITH ALL VOLVO S80 WITH V8 ENGINE.
THE FRONT SUBFRAME OF MY VEHICLE WAS FOUND TO BE UNSAFE BY THE VOLVO DEALER IN MY AREA. CORROSION HAD GREATLY DETERIORATED PARTS OF THE FRAME WHICH SUPPORTS THE FRONT SUSPENSION, STEERING AND ENGINE. I WAS TOLD THAT REPLACEMENT WAS THE ONLY OPTION TO AVOID A POTENTIALLY CATASTROPHIC FAILURE WHILE DRIVING. CLOSE EXAMINATION REVEALED SIGNIFICANT LOSS OF STRUCTURAL INTEGRITY OF THE SUBFRAME. VOLVO SERVICE STAFF TOLD ME THIS WAS A COMMON PROBLEM FOR THIS MODEL S80 V8.
DRIVER DOOR LOCK AND LATCH MECHANISM SEEMS TO GLITCH OUT, LEAVING DOOR IMPOSSIBLE TOCLOSE . IT TENDS TO REACTIVATE AFTER DRIVING FOR A FEW MINUTES WITH THE DOOR OPEN WARNING LIGHT ON. WEATHER DOESNT SEEM TO EFFECT IT LIKE FROZEN LOCKS. THIS ISSUE HAS HAPPENED ON RANDOMLY EVEN ON 50 DEGREE DAYS. IT SEEMS TO BE A COMMON ISSUE ON THE VOLVO FORUMS.
WINDSHIELD LEAK. AFTER A RECENT RAIN STORM (APRIL 2017), THE PASSENGER SIDE CARPETING WAS SOAKED. TOOK THE CAR TO MY LOCAL VOLVO DEALERSHIP AND THEY VERIFIED THE WINDSHIELD SEAL WAS LEAKING (UNSOUND) AT THE TOP. THEY REFERRED ME TO A LOCAL AUTO GLASS COMPANY WHO TOLD ME THEY HAVE SEEN THIS ON SEVERAL VOLVO'S WHERE THE SEAL WAS NOT PROPERLY BONDED AT THE FACTORY. I HAVE SEARCHED FOR RECALLS, BULLETINS,ETC. BUT HAVE NOT FOUND ANY INFORMATION REGARDING THIS DEFECT. IF IN FACT IT IS A FACTORY DEFICIENCY I BELIEVE I SHOULD BE REIMBURSED FOR THE REPAIR OR REPLACEMENT OF THE WINDSHIELD.
OIL LEAKING FROM HOLE OR CRACKED ENGINE ALOT OF OIL DRIPPING IN THE EXAUST PIPES VERY DANGER SITUATION
TL* THE CONTACT OWNS A 2007 VOLVO S80. WHILE THE CONTACT'S HUSBAND WAS DRIVING 30 MPH AND MAKING A TURN, AN ABNORMAL "POP" SOUND WAS HEARD AND THE STEERING WHEEL BECAME DIFFICULT TO TURN WITHOUT WARNING. THE VEHICLE WAS DRIVEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE POWER STEERING HOSE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE STEERING FAILED AGAIN. THE VEHICLE WAS TAKEN BACK TO THE INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE POWER STEERING PUMP/RESERVOIR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
THE PASSENGER SIDE HEAD LIGHT WHILE I WAS DRIVING HOME FROM WORK BULB WENT OUT HAD MESSAGE STATING BULB FAILURE REPLACED BULBS AND WITHIN 2 DAYS. LIGHTS WERE OUT AGAIN AND THE WIRING CONNECTED TO HEAD LIGHTS WERE FRAYED AS IF THEY HAD SHORTED OUT OR HAD MELTED AND THE BACK SIDE SIGNAL ON PASSENGER SIDE STOPPED WORKING THE CAR WAS BEING DRIVEN AT THAT TIME
THIS CAR LEAK OIL EVERY WHERE THE VALVE COVER GASKET BREAK DOWN BECAUSE OF THE POR COOLING SYSTEM DESIGN AND THE POWER STEERING PUMP SPRAY OIL EVERY WHERE THE OIL GETS BURN IN THE EXAUST
Showing 15 of 24 complaints