Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2002 Volvo Vnl.
NHTSA has not published 5-star crash-test ratings for the 2002 Volvo Vnl. New vehicles are often added to the NCAP rating program after initial release; check nhtsa.gov/ratings for the latest status.
Component: STEERING:LINKAGES:DRAG:LINK:CONNECTION
VOLVO TRUCKS IS RECALLING CERTAIN MODEL YEAR 2001-2006 VNL AND VNM TRUCKS MANUFACTURED WITH A TRW SEALED DRAG LINKS. CERTAIN FACTORS CAN EXIST, WHICH IF LEFT UNTREATED MAY RESULT IN A BALL SOCKET SEPARATION.
Consequence: BALL SOCKET SEPARATION AT THE DRAG LINK RESULTS IN COMPLETE LOSS OF STEERING, AND THEREFORE CAN RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT AND REPAIR THE BALL SOCKET OR THE DRAG LINK AS REQUIRED IF NECESSARY. AS PARTS ARE LIMITED, VOLVO TRUCKS MAILED AN INTERIM OWNER LETTER ON SEPTEMBER 2, 2010. THE SAFETY RECALL BEGAN ON FEBRUARY 14, 2011. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
Component: VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
VOLVO TRUCKS IS RECALLING 127,764 MY 2001-2008 VHD, VNL, VNM, AND MY 2005-2008 VT TRUCKS. A SEAL MAY FAIL ALLOWING WATER AND CONTAMINANTS TO SEEP INTO THE WINDSHIELD WIPER MOTOR.
Consequence: IF THIS HAPPENS A SHORT CIRCUIT MAY OCCUR, WHICH OVER TIME COULD POSSIBLY LEAD TO A VEHICLE FIRE.
Remedy: VOLVO WILL REPLACE THE WIPER MOTOR FREE OF CHARGE. SINCE THIS RECALL INVOLVES A LARGE NUMBER OF VEHICLES, VOLVO WILL RELEASE THE RECALL IN STAGES AS PARTS ARE RECEIVED. PRIORITY WILL BE GIVEN TO THE VEHICLES LOCATED IN THE REGIONS/STATES THAT HAVE A CORROSIVE ENVIRONMENT. THE RECALL BEGAN ON SEPTEMBER 30, 2009. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
Component: ELECTRICAL SYSTEM:WIRING
ON CERTAIN TRUCKS, THE WIRING HARNESS CONNECTED TO THE CHASSIS MOUNTED ELECTRICAL INVERTER MAY ALLOW WATER TO ENTER THE INVERTER AND CAUSE AN ELECTRICAL SHORT IN THE INVERTER.
Consequence: THIS COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE VEHICLES. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING AUGUST 2003. OWNERS SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
Component: EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
ON CERTAIN HEAVY-DUTY TRUCKS, WHEN THE BUNK IS RAISED INTO THE STORED POSITION, AN OBJECT LEFT ON THE BUNK MAY INADVERTENTLY TURN ON A BUNK LAMP.
Consequence: THIS COULD POSSIBLY RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A BUNK LAMP WITH A PUSH BUTTON ON/OFF SWITCH. OWNER NOTIFICATION BEGAN ON DECEMBER 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCK AT 1-800-528-6586.
Component: TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH JOST INTERNATIONAL JSK 37U SERIES FIFTH WHEELS, A FATIGUE CRACK CAN DEVELOP IN THE BRACKET PIN WELD UNDER CERTAIN LOADING CONDITIONS.
Consequence: IF LEFT UNDETECTED OR CORRECTED IT COULD LEAD TO THE SEPARATION OF THE FIFTH WHEEL TOP PLATE FROM ITS MOUNTING STRUCTURE, POSSIBLY RESULTING IN A CRASH.
Remedy: DEALERS WILL REPLACE THE BRACKET PINS AND REPAIR INSTRUCTIONS FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT JOST INTERNATIONAL AT 616-846-7700 OR BY EMAIL TO RECALL@JOSTINTERNATIONAL.COM OR VOLVO TRUCK AT 800-528-6586.
Component: SUSPENSION:FRONT
ON CERTAIN TRUCKS EQUIPPED WITH TRUCK HUB UNITS MANUFACTURED BY SKF EXCLUSIVELY FOR USE ON ARVINMERITOR'S FF98X SERIES NON-DRIVE STEER AXLES, THE HUB UNIT BEARINGS CAN WEAR PREMATURELY.
Consequence: SEIZURE OF THE BEARINGS CAN CAUSE WHEEL SEPARATION OR WHEEL END FIRE.
Remedy: DEALERS WILL REPLACE ALL FRONT AXLE HUBS. AN INTERIM NOTICE TO OWNERS WAS MAILED ON JUNE 25, 2003. FINAL OWNER NOTIFICATION BEGAN ON OCTOBER 6, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-528-6586.
Component: EXTERIOR LIGHTING:TAIL LIGHTS:SWITCH
CERTAIN HEAVY DUTY CLASS 8 TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE TWO TAIL LAMPS, BACK-UP LAMP,AND LICENSE TAG LAMP WERE MOUNTED ON INSUFFICIENTLY RIGID MOUNTS.
Consequence: IT MAY NOT ALLOW THE DRIVER OF A REARWARD APPROACHING VEHICLE TO HAVE FULL VIEW OF THE LAMPS.
Remedy: DEALERS WILL ATTACH THE TWO TAIL LAMPS, BACK-UP LAMP, AND THE LICENSE TAP LAMP ON STIFFER BRACKETS. OWNER NOTIFICATION BEGAN OCTOBER 31, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
DT: CALLER HAD A HEAVY DUTY TRUCK. CALLER SAID HE COULD NOT STOP THE VEHICLE IN AN EMERGENCY IF THE BRAKES FAILED. CALLER HAD IT IN THE SHOP SEVERAL TIMES. THE DEALER TOLD HIM THEY COULD NOT FIND WHAT WAS WRONG WITH IT. MANUFACTURER SAID TO TAKE IT TO A LOCAL DEALER, WHO GUESSED AT WHAT WAS WRONG AND REPLACED PARTS, BUT THEY NEVER SOLVED THE PROBLEM.*AK THE CONSUMER STATED THE JAKE BRAKE WAS VERY WEAK. UPDATED 12/07/05 *JB
The 2002 Volvo Vnl has 7 NHTSA recalls and 1 consumer complaint on file. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.