Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 1990 Chevrolet Suburban.
NHTSA has not published 5-star crash-test ratings for the 1990 Chevrolet Suburban. New vehicles are often added to the NCAP rating program after initial release; check nhtsa.gov/ratings for the latest status.
Component: FUEL SYSTEM, GASOLINE
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Component: POWER TRAIN:AUTOMATIC TRANSMISSION
UNANTICIPATED HEAT IN THE TRANSMISSION CAN FORCE THE TRANSMISSION FLUID OUT OF THE VENT TUBE.
Consequence: THE VENTED TRANSMISSION FLUID CAN CATCH FIRE IF EXPOSEDTO A SOURCE OF IGNITION.
Remedy: INSTALL A LONGER TRANSMISSION VENT HOSE ROUTED TO THE LEFT SIDE OF THE ENGINE COMPARTMENT OF THE VEHICLE.
Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
CONSUMER TOOK VEHICLE IN TO HAVE TIRES BALANCED DUE TO VIBRATION AND WAS ADVISED TIRES WERE SEPARATING, CONSUMER WAS INFORMED THAT THESE TIRES WERE NOT PART OF ANY RECALL, SO CONSUMER PURCHASED FOUR NEW TIRES, 2 WEEKS LATER CONSUMER REPORTS INDICATED THAT THE TIRES WERE ON RECALL, SO CONSUMER FILLED OUT A FORM AND SENT IT IN, HOWEVER HAS HEARD NO RESPONSE, FIRESTONE WILDERNESS AT, P235/75R15, DOT W2HL1PY407. *SLC
CONSUMER STATED VEHICLE WAS VIBRATING, VEHICLE WAS TAKEN INTO SHOP AND CONSUMER WAS INFORMED THAT TIRES WERE SEPARATING, WHICH WERE REPLACED AT THE CONSUMER EXPENSE AFTER BEING TOLD THAT THEY WERE NOT APART OF ANY RECALL, THE TIRES THAT CONSUMER PURCHASED, HOWEVER WERE ON RECALL, CONSUMER HAS BEEN UNABLE TO GET A REPSONSE FROM FIRESTONE. (FIRESTONE WILDERNESS AT TIRES P235/75R15)*YH
CONSUMER STATED VEHICLE WAS VIBRATING, VEHICLE WAS TAKEN INTO SHOP AND CONSUMER WAS INFORMED THAT TIRES WERE SEPARATING, WHICH WERE REPLACED AT THE CONSUMER EXPENSE AFTER BEING TOLD THAT THEY WERE NOT APART OF ANY RECALL, THE TIRES THAT CONSUMER PURCHASED, HOWEVER WERE ON RECALL, CONSUMER HAS BEEN UNABLE TO GET A REPSONSE FROM FIRESTONE. (FIRESTONE WILDERNESS AT TIRES P235/75R15)*YH
The 1990 Chevrolet Suburban has 4 NHTSA recalls and 65 consumer complaints on file. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Consequence: SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy: REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
Component: SEATS
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL BETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Consequence: IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULDALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLECONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
PE00 020; CONSUMER WAS TRAVELING 65MPH ON HIGHWAY AND HEARD A NOISE, TREAD WAS FLAPPING UP AGAINST INNER FENDER WELL. HE WAS ABLE TO PULL OVER TO THE SHOULDER , AND NOTICED THAT THE DRIVER'S SIDE REAR TIRE TREAD SEPARATED. THE TIRE FIRESTONE, STEEL TEX, LT23585R16, DOT VN0RTXK127. DEALERSHIP WAS AWARE OF PROBLEM.*AK
THE LEFT REAR TIRE BLEW OUT ON I 95 WHILE TRAVELING AT APPROX. 70 MPH. THIS CAUSED THE TRUCK TO SWAY BACK AND FORTH FROM THE LEFT LANE THEN BACK INTO THE RIGHT LANE SEVERAL TIMES. I WAS LUCKY THAT NOBODY WAS BESIDE ME AT THE TIME. WHEN I PULLED OFF THE ROAD I SAW THAT THE WHOLE TREAD WAS GONE OFF THE TIRE. IT BENT UP THE QUARTER PANEL AND RIPPED THE TAILPIPE OUT OF THE MUFFLER. THE TREAD HAD HIT SOME OTHER CARS AND WAS ABOUT 1/4-1/2 A MILE DOWN THE ROAD. THE TIRES ALL HAVE LARGE BULGES OF UNEVEN TREADS. I CALLED GOODYEAR AND TOLD THEM THE PROBLEM. THEY SAID THEY DONT HAVE ANY PROBLEMS WITH THESE TIRES AND ANY WEAR PROBLEMS ARE PROBABLY THE FAULT OF MY VEHICLE. THEY DID SAY THEY WANT THE BLOWN TIRE AND WILL REPLACE IT, BUT WILL NOT REPLACE THE OTHERS. SO THEY ARE ALL IN MY GARAGE WAITING FOR A RECALL. THEY ARE DANGEROUS. IF YOU HAVE ANY QUESTIONS, CALL ME AT MY WORK #. THANK YOU. *AK (TIRESIZE: 31/10.5/15)( DOT NUMBER: TIRE SIZE: 31/10.5/15 )
WINDSHIELD WIPERS WILL QUIT RUNNING INTERMITTENTLY, CAUSING POOR VISIBILITY. CONSUMER HAS SAME DEFECT AS RECALL 98V150001, BUT MANUFACTURER CLAIMED THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. *AK
ABOUT 1 MILE AFTER GETTING OFF THE FREEWAY, I WAS TRAVELING 35 MPH ON A WELL PAVED SURFACE STREET WHEN LEFT REAR OF THE VEHICLE STARTED TO SHAKE AND VEER TO THE LEFT SUDDENLY. I WAS ABLE TO CONTROL THE VEHICLE AND SLOWLY SLOW DOWN BEFORE THE TREAD SEPARATED FROM THE TIRE BUT IT DID NOT COMPLETELY DETACH FROM THE TIRE. ABOUT ONE-THIRD OF THE TREAD STAYED ATTACHED TO THE STEEL BELTS AND THIS CAUSING A SLAPPING OF THE DETACHED PORTION OF THE TREAD AGAINST THE BODY OF THE VEHICLE. I WAS ABLE TO STOP THE VEHICLE IN ABOUT 300 FEET WITHOUT AN ACCIDENT. THE TIRE WAS STILL FULLY INFLATED WHEN THE TOW TRUCL DRIVER CMAME TO PUT ON MY SPARE TIRE. THE FIRESTONE DEALER REFUSED TO GIVE ME ANY ADJUSTMENT OR ALLOWANCE TOWARD REPLACING THE TIRE OR THE REMAINING 3 OTHER TIRES. SINCE I WAS NOT PLEASED WITH THE FIRESTONE DEALER'S ANSWER AND FELT THAT THE OTHER 3 TIRES COULD ALSO BE HAZARDOUS, I BOUGHT FOUR TIRES FROM GOODYEAR TO BE SAFE. THE ONLY REASON I AM WRITING IS SO THAT THE NHTSA WILL BE AWARE THAT THE TIRE SEPARATION PROBLEM ON FIRESTONE TIRES IS ALSO PRESENT IN THE 16 INCH SIZES. PLEASE, PLEASE, PLEASE ISSUE A WARNING TO OWNERS OF THIS SIZE TIRE ALSO SO AT LEAST THOSE DRIVERS CAN BE AWARE OF POTENTIAL PROBLEMS WITH THEIR TIRES THAT COULD KILL THEM OR THEIR VEHICLE OCCUPANTS IF A TREAD SEPARATION SHOULD OCCUR AT FREEWAY SPEEDS. I KNOW THAT IF THE SEPARATION HAD OCCURRED ON MY VEHICLE JUST ONE MILE EARLIER WHEN I WAS ON THE FREEWAY DOING 65 MPH, I COULD EASILY HAVE LOST CONTROL OF THE VEHICLE AND NOT HAVE HAD THE ABILITY TO PREVENT A SERIOUS ACCIDENT OR FATALITY TO MYSELY, MY OCCUPANTS, OR PERHAPS OTHER VEHICLES ON THE ROAD THAT DAY. AGAIN, PLEASE NOTIFY THE DRIVERS OF VEHICLES WITH THE 16 FIRESTONE TIRES THAT THEY ARE ALSO AT EXTREME RISK, NOT ONLY THE 15 INCH TIRES. *AK (TIRESIZE: 235-85-R16)( DOT NUMBER: TIRE SIZE: 235-85-R16 )
ABOUT 1 MILE AFTER GETTING OFF THE FREEWAY, I WAS TRAVELING 35 MPH ON A WELL PAVED SURFACE STREET WHEN LEFT REAR OF THE VEHICLE STARTED TO SHAKE AND VEER TO THE LEFT SUDDENLY. I WAS ABLE TO CONTROL THE VEHICLE AND SLOWLY SLOW DOWN BEFORE THE TREAD SEPARATED FROM THE TIRE BUT IT DID NOT COMPLETELY DETACH FROM THE TIRE. ABOUT ONE-THIRD OF THE TREAD STAYED ATTACHED TO THE STEEL BELTS AND THIS CAUSING A SLAPPING OF THE DETACHED PORTION OF THE TREAD AGAINST THE BODY OF THE VEHICLE. I WAS ABLE TO STOP THE VEHICLE IN ABOUT 300 FEET WITHOUT AN ACCIDENT. THE TIRE WAS STILL FULLY INFLATED WHEN THE TOW TRUCL DRIVER CMAME TO PUT ON MY SPARE TIRE. THE FIRESTONE DEALER REFUSED TO GIVE ME ANY ADJUSTMENT OR ALLOWANCE TOWARD REPLACING THE TIRE OR THE REMAINING 3 OTHER TIRES. SINCE I WAS NOT PLEASED WITH THE FIRESTONE DEALER'S ANSWER AND FELT THAT THE OTHER 3 TIRES COULD ALSO BE HAZARDOUS, I BOUGHT FOUR TIRES FROM GOODYEAR TO BE SAFE. THE ONLY REASON I AM WRITING IS SO THAT THE NHTSA WILL BE AWARE THAT THE TIRE SEPARATION PROBLEM ON FIRESTONE TIRES IS ALSO PRESENT IN THE 16 INCH SIZES. PLEASE, PLEASE, PLEASE ISSUE A WARNING TO OWNERS OF THIS SIZE TIRE ALSO SO AT LEAST THOSE DRIVERS CAN BE AWARE OF POTENTIAL PROBLEMS WITH THEIR TIRES THAT COULD KILL THEM OR THEIR VEHICLE OCCUPANTS IF A TREAD SEPARATION SHOULD OCCUR AT FREEWAY SPEEDS. I KNOW THAT IF THE SEPARATION HAD OCCURRED ON MY VEHICLE JUST ONE MILE EARLIER WHEN I WAS ON THE FREEWAY DOING 65 MPH, I COULD EASILY HAVE LOST CONTROL OF THE VEHICLE AND NOT HAVE HAD THE ABILITY TO PREVENT A SERIOUS ACCIDENT OR FATALITY TO MYSELY, MY OCCUPANTS, OR PERHAPS OTHER VEHICLES ON THE ROAD THAT DAY. AGAIN, PLEASE NOTIFY THE DRIVERS OF VEHICLES WITH THE 16 FIRESTONE TIRES THAT THEY ARE ALSO AT EXTREME RISK, NOT ONLY THE 15 INCH TIRES. *AK( DOT NUMBER: TIRE SIZE: 235-85-R16 )
TREAD SEPARATED, CAUSING TIRE TO BLOWOUT. *AK (DOT NUMBER: W2M2 JBA TIRESIZE: 255/70R15)
TREAD SEPARATED, CAUSING TIRE TO BLOWOUT. *AK( DOT NUMBER: W2M2 JBA TIRE SIZE: 255/70R15 )
AFTER BRAKING 2 TO 3 TIMES THE BRAKES STAGGER, SHUDDER GRABBING AND STICKING, SEEMS LIKE THE ANTILOCK SYSTEM IS HAPPENING EACH AND EVERY TIME BRAKES ARE APPLIED.
THE LEFT REAR FIRESTONE FIREHAWK (235/75R15) TIRE SUSTAINED A TREAD SUSTAINED A TREAD SEPARATION CAUSING THE VEHICLE TO ROLLOVER, FIVE OCCUPANTS SUSTAINED INJURIES (ATTORNEY FOR CLIENT). NLM
WHILE DRIVING, THE TREAD SEPARATED FROM SIX DIFFERENT FIRESTONE ATX TIRES WITHIN 20,000 MILES. THIS ALWAYS OCCURED ON A HIGHWAY IN TEXAS. THE DATES WERE 10/96, 10/96, 5/97, 12/98, 3/99, & 6/99.( DOT NUMBER: TIRE SIZE: 321150R15 )
PE 00 020/TRIE TREAD SEPARATION: WHILE TRAVELING AT HIGHWAY SPEED OF 60 MPH, RIGHT REAR TIRE EXPERIENCED A TREAD SEPARATION ON A 1990 CHEVROLET SUBURBAN, AFTERMARKET EQUIPMENT; P235/75R15; DOT# UNAVAILABLE. DRIVER / TWO PASSENGERS INVOLVED, NO INJURY REPORTED. PLEASE FEEL FREE TO PROVIDE ANY FURTHER DETAILS. *AK FIRESTONE WILDERNESS AT P235/75/R15 *MW
TRUCK ACCERERATED SOUNDED LIKE OVER 100 MPH BUT WAS GOING SLOW SPEEDCOULD NOT STOPR TRUCK TURNED OFF IN STREET AND JUMPED OUT CAR REAR END BROKE AND U-JOINT. VERY DANGEROUS. *AK
Showing 15 of 65 complaints