Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 1991 Chevrolet Suburban.
NHTSA has not published 5-star crash-test ratings for the 1991 Chevrolet Suburban. New vehicles are often added to the NCAP rating program after initial release; check nhtsa.gov/ratings for the latest status.
Component: FUEL SYSTEM, GASOLINE
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Component: POWER TRAIN:AUTOMATIC TRANSMISSION
UNANTICIPATED HEAT IN THE TRANSMISSION CAN FORCE THE TRANSMISSION FLUID OUT OF THE VENT TUBE.
Consequence: THE VENTED TRANSMISSION FLUID CAN CATCH FIRE IF EXPOSEDTO A SOURCE OF IGNITION.
Remedy: INSTALL A LONGER TRANSMISSION VENT HOSE ROUTED TO THE LEFT SIDE OF THE ENGINE COMPARTMENT OF THE VEHICLE.
Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
I HAVE A SET OF HANKOOK OPTIMO 727 TIRES ON MY FAMILY SUBURBAN, AND ONE OF THEM BLEW OUT SUDDENLY, AND UNEXPECTEDLY. THE TIRE THAT BLEW OUT ONLY HAD 14,596 MILES ON IT. THE SIZE IS P235-75-15. ALL FOUR OF THESE TIRES WERE INSTALLED IN FEBRUARY 2016, AND THE VEHICLE WAS ALWAYS KEPT IN MY GARAGE. THE TIRE THAT BLEW OUT SHOWED NO SIGNS OF SUN OZONE DEPLETION, AND AGAIN, IT NEVER SAT OUTSIDE IN THE SUN. ADDITIONALLY, THE TIRE THAT BLEW OUT HAD ALOT OF TREAD DEPTH LEFT. THE VEHICLE WAS NOT OVERLOADED, AS I WAS THE ONLY PERSON IN IT AT THE TIME OF THE BLOWOUT. I WAS SIMPLY DRIVING ABOUT 72 MPH DOWN INTERSTATE 65, JUST SOUTH OF LOUISVILLE, KY, I FELT SOME VIBRATION FOR ABOUT ONE MINUTE, THEN BOOM!, THE TIRE LET GO. I'M DISAPPOINTED IN HANKOOK TIRES, AND WILL NEVER BUY ANOTHER.
FRAME WHERE STEERING BOX IS ATTACHED FAILED. FLEXING FROM NORMAL USE CAUSED THE AREA AROUND THE MOUNTING BOLTS TO CRACK AND WOULD ULTIMATELY SEPARATE THE STEERING BOX FROM THE FRAME IF LEFT UNREPAIRED. REPORTS OF FRAME FAILURES ON 4X4 VERSIONS HAVE BEEN CIRCULATING FOR SOME YEARS DUE TO THE HIGHER STRESS CAUSED BY THE FRONT AXLE AND THE USE OF OVERSIZED TIRES. IN THIS CASE THE SUBURBAN IS A 1/2 TON 2WD UNIT AND HAS ALWAYS RUN ON FACTORY SIZED TIRES. CRACKS WERE FIRST NOTICED JANUARY 2005 WITH 106744 MI DURING A REPAIR JOB FOR A LOOSE FRAME RIVET. CURRENTLY, DECEMBER 2010 AND 206000 MI., CRACKS HAVE FORMED ON ALL MOUNTING LOCATIONS AND REQUIRES A FRAME REPAIR KIT. REPAIR INCLUDES GRINDING AND WELDING OF CRACKS; AND WELDING ADDITIONAL REENFORCING PLATES TO STRENGTHEN THE AREA.
The 1991 Chevrolet Suburban has 4 NHTSA recalls and 57 consumer complaints on file. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Consequence: SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy: REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
Component: SEATS
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL VETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Consequence: IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULD ALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLE CONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
TREAD SEPARATION AROUND 9/10 OF TIRE STEEL BELTS SHOWING. RUBBER SEPARATING FROM SAME. *TR
PEP BOYS FUTURA SCRAMBLER A/P TRUCK TIRE BLOWOUT DUE TO BELT SEPARATION. *TR
TL*THE CONTACT OWNS A 1991 CHEVROLET SUBURBAN. WHILE DRIVING 60 MPH, THE CONTACT EXPERIENCED VALVE STEM FAILURE, WHICH CAUSED IT TO CRACK. THE TIRE FLATTENED AND WAS RUINED AS A RESULT. THE DEALER STATED THAT THEY NEVER HEARD OF THE VALVE STEM FAILURE. THROUGH ONLINE RESEARCH, THE CONTACT EXPERIENCED VARIOUS RECALLS PERTAINING TO VALVE STEM FAILURES AND CRACKS. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 51,000. THE TIRE FAILURE MILEAGE WAS APPROXIMATELY 12,000.
THE BRAKE ROTORS HAD SEPARATED. THE BRAKES ON THIS VEHICLE ARE DEFECTIVE. THE SAME PART FOR THE BRAKES WERE REPLACED FOR THE RECALL BRAKE PART AND THE PROBLEM STILL EXIST. THE CONSUMER CONTACTED THE MANUFACTURER AND WAS INFORMED THAT THE CAMPAIGN WAS CLOSED AND WAS NOT ABLE TO INDICATE WHAT WAS REPAIRED DUE TO NOT BEING THE ORIGINAL OWNER RECALL 93V119000. *CM *SCC
THE BRAKE PEDAL WENT TO THE FLOOR WHEN PRESSED WHICH RESULTED IN EXTENDED STOPPING DISTANCE. *NLM
BRIDGESTONE LT 23585R16 DOTEP9JHND205 WHILE DRIVING AT NORMAL SPEEDS THE LEFT REAR TIRE SEPERATED AND DEFLATED, WHICH RESULTED IN A VEHICLE CRASH. PLEASE PROVIDE ANY FURTHER INFORMATION. MR
WHILE DRIVING 60-65 MPH AND TOWING A TRAILER, 2 LUG BOLTS SNAPPED OFF THE HUB AND ONE OTHER BOLT WAS LOOSE CAUSING VEHICLE TO JACKKNIFE AND DROVE OFF THE ROAD. THE TRAILER SEPARATED FROM THE VEHICLE AND TURNED IN A DITCH. THE REMAINING LUG BOTLS WERE MISSING THREADS. THERE WERE NO INJURIES.(OHIO TRAFFIC REPOERT#10-90-210) *TT
ON THE 18TH OF MAR 2001, AFTER FILLING UP MY GAS TANK, I GOT IN MY VEHICLE ATTEMPTED TO PUT MY SEAT BELT ON AND ENDED UP LYING FLAT ON MY BACK. AS LUCK WOULD HAVE NO KIDS WERE SITTING BEHIND ME. A SINGLE GRADE 8 BOLT BROKE. A FEW YEARS BACK WHEN THIS VEHICLE HAD ABOUT 100K ON IT THE SAME THING HAPPENED. AT THAT TIME THE DEALER (PERFORMANCE CHEVY IN SACRAMENTO CA) TOLD ME THERE WAS A CAMPAIN TO REPLACE THE BOLTS FROM GRADE 5 TO GRADE 8. APPARENTLY THE GRADE 5 LASTED LONGER THAN THE GRADE 8. THE DEALER HERE IN OGDEN SAYS THE VEHICLE IS TO OLD AND THERE IS NO PROVISION FOR MAKING THIS A SAFER SEAT. IF THIS HAD ACCURED WHILE DRIVING THERE ISNO TELLING WHAT MIGHT HAVE HAPPENED. I AM NOT A COMPLAINER BUT THIS WHOLE THING SEEMS WRONG. AND WHEN I GO TO SELL THIS VEHICLE HOW CAN I SAY IT IS A SAFE CAR. HOPE YOU CAN HELP,AND I APPRECIATE YOU LOOKING INTO THIS, I CANT BELIEVE I AM THE ONLY ONE WITH THIS PROBLEM.. PHILLIP WILLIAMS. *AK
ENGINE OIL COOLING LINES FROM ENGINE OIL FILTER TO ENGINE OIL COOLER WEAR AGAINST FRAME UNDER ENGINE, AND MAY CAUSE BAD ENGINE OIL LEAK . I HAVE SEEN THIS PROBLEM TWO TIMES ONCE ON MY OWN TRUCK AND ON A FRIENDS TRUCK OF THE SAME MAKE MODEL YEAR AND GENERAL EQUIPMENT. *AK
INTERMITTENTLY WHEN BRAKES ARE APPLIED AT SPEEDS OF 45 AND ABOVE VEHICLE VIBRATED UNCONTROLLABLY, RESULTING IN EXTENDED STOPPING DISTANCE. *AK
TREAD SEPARATION AT HIGHWAY SPEED. ONE TIRE SHOWED A SMALL "BALLOON" ON THE SIDEWALL. I REPLACED IT. THE NEXT DAY, A DIFFERENT GOODYEAR TIRE HAD MASSIVE TREAD SEPARATION ON THE INTERSTATE.( DOT NUMBER: TIRE SIZE: 30X9.50R15 )
DEAR NHTSA, I HAD MANY TIRE FAILURES WITH MY FIRESTONE ATX II TIRES. I PURCHASED THEM WHEN MY CAR HAD 57,358 MILES ON 03/19/94. I DROVE APPROXIMATELY 20,000 MILES PER YEAR. ALL THE PREVIOUS TIRE FAILURES WERE BLOWOUTS I HAD WHILE DRIVING WITH MY FAMILY ON THE HIGHWAY. EACH TIME I WENT TO THE FIRESTONE SERVICE CENTER FOR PRORATED TIRE REPAIRS. THEY KEPT TRYING TO BLAME MY BLOWOUTS ON MY ALUMINUM WHEEL RIMS ALTHOUGH I NEVER HAD ANY PROBLEMS WITH MY PREVIOUS UNIROYAL TIRES. IN 1998 AFTER YET ANOTHER TIRE PROBLEM I SWITCHED TO MICHELINS, AND I HAVE SINCE SOLD THE VEHICLE IN 8/99. AT THE TIME OF THESE PROBLEMS, I WAS CONCERNED AS TO THE AMOUNT OF BLOWOUTS I HAD, AND UNTIL THE RECALL CAME OUT I THOUGHT IT MIGHT BE OF SOME RELEVANCE TO YOU. I HAVE ALL MY ORIGINAL PAPERWORK FROM FIRESTONE. MANY OF THE REPLACEMENT TIRES I HAD CARRIED IN TO THE STORE SO I DON'T HAVE EXACT MILAGE OF THE TIRES. I DO POSSIBLY HAVE AT LEAST ONE OF THESE TIRES ON MY PROPERTY BUT IT WOULD REQUIRE SOME EFFORT TO RETRIEVE AND FIND IT. I BELIEVE THAT THE PROBLEM WITH THESE TIRES HAS BEEN GOING ON FOR A LOT LONGER THAN FIRESTONE HAS LED ME TO BELIEVE AND I WOULD BE WILLING TO HELP YOU IN ANY WAY I CAN. I AM ALSO GOING TO CONTACT FIRESTONE' S WEBSITE AND GIVE THEM THIS INFORMATION AS WELL. SINCERELY LISA R. KING( DOT NUMBER: ? TIRE SIZE: P235-75-15 )
SEAT BELT RETRACTOR, SECOND ROW BEHIND DRIVER, LOCKED UP AND UNABLE TO BE USED, CAUSING PASSENGER IN THAT SEAT TO BE WITHOUT RESTRAINT. DEALER NOTIFIED AND REFUSED TO REPAIRS UNLESS COST GOES TO CONSUMER. *AK
Showing 15 of 57 complaints