Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 1994 Dodge Caravan.
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS
VEHICLE DESCRIPTION: MINI VANS. THE BOLTS USED TO ATTACH THE STRUT TO THE BODY AND THE REAR LIFTGATE CAN ACCUMULATE FATIGUE DAMAGE IF THREE FACTORS COMBINE. IF THE BOLT IS LOOSE, THE GAS STRUT IS OVER-PRESSURIZED, AND THE FREQUENCY OF OPENING AND CLOSING CYCLES IS HIGHER THAN FOR THE AVERAGE CUSTOMER, THE BOLT CAN FAIL.
Consequence: PERSONAL INJURY COULD OCCUR IF THE BOLTS BREAK ALLOWING THE LIFTGATE TO FALL SUDDENLY.
Remedy: DEALERS WILL INSPECT FOR LOOSE FASTENERS, IF THE FASTENERS ARE LOOSE, THE STRUT (AND INTEGRAL BOLTS) WILL BE REPLACED. IF THE BOLT SHOWS EVIDENCE OF TORQUE, THE BOLT WILL BE REMOVED, LARGER WASHERS WILL REPLACE THE EXISTING WASHER AND THE BOLT WILL BE REINSTALLED AND HAND TIGHTENED TO THE TARGET TORQUED.
Component: STEERING: STEERING WHEEL/HANDLE BAR
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH 2-SPOKE LUXURY WHEELS MANUFACTURED JULY 1992 THROUGH JUNE 1993; OR EQUIPPED WITH 4-SPOKE SPORT WHEELS MANUFACTURED FROM JULY 1992 THROUGH SEPTEMBER 1993. THE STEERING WHEEL ARMATURE STAMPING CAN CRACK AND SEPARATE FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN.
Consequence: IF THE STEERING WHEEL SEPARATES FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN, LOSS OF CONTROL CAN OCCUR INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL FOR CRACKS AND ANY WHEELS WITH CRACKS WILL BE REPLACED. ALL OTHER VEHICLES WILL HAVE A REINFORCEMENT PLATE INSTALLED TO PREVENT STEERING WHEEL SEPARATION IN THE EVENT CRACKING OCCURS.
MY AIR BAG LIGHT IS ON BECAUSE THE REAR WIPER SHORTED OUT AND BLEW THE FUSE, AND THE AIR BAGS ARE ON THE SAME FUSE.
DRIVING DOWN INTERSTATE VEHICLE JUST QUIT. WAS ABLE TO COAST TO SIDE OF ROAD. ATTEMPT TO RESTART FAILED.4 TIMES. LET VEHICLE SIT FOR ABOUT 10 MINUTES AND NORMAL RESTART. THIS IS THIRD TIME IN THREE WEEKS. OTHER TWO NO STARTS WERE AFTER VEHICLE SITTING OVERNIGHT. NO ERROR CODES OR CHECK ENGINE LIGHT. FIRST NO START REPLACED AIR FILTER. SECOND NO START REPLACED BATTERY. INFO PROVIDED BECAUSE OF 2010 DODGE GRAND CARAVAN ISSUE AN POTENTIAL FOR IT TO EXIST IN EARLY VEHICLES. I DO NOT BELIEVE IT IS THE IGNITION SWITCH. *TR
AS I SLOWLY WAS TURNING THE CAR TO PARK IN A PARKING LOT IN VIENNA VA SHOPPING CENTER, THE VAN SUDDENLY ACCELERATED ON ITS OWN AND STOPPED WHEN IT CRASHED INTO HANDICAP PARKING POLE MARKER ( NO DAMAGE). DAMAGE TO MY VAN WHICH IS VISABLE APPEARS TO BE THE FRONT OF THE HOOD OF THE CAR AND A DAMAGED BUT FUNCTIONING RADIATOR AS BEST I CAN SEE. NOTE: THE AIR BAGS WERE NOT ACTIVEATED, AND WONDERED WHY THEY DIDN'T.( IS THIS ANOTHER PROBLEM ?) *TR
The 1994 Dodge Caravan has 5 NHTSA recalls and 772 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: LATCHES/LOCKS/LINKAGES:HATCHBACK/LIFTGATE:LOCK
VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER MINIVANS WITH REMOTE RELEASE. THIS IS NOT A SAFETY RECALL. THERE HAS BEEN NO DETERMINATION THAT A SAFETY DEFECT EXISTS WITH THE MINIVAN LATCHES. CHRYSLER IS CONDUCTING A SERVICE CAMPAIGN TO REPLACE THE LIFTGATE LATCH ASSEMBLY OF THE AFFECTED MINIVANS. IN A COLLISION, THE REAR LIFTGATE LATCH ASSEMBLY COULD OPEN.
Consequence: IF THE LIFTGATE LATCH OPENS, OCCUPANTS CAN BE EJECTED RESULTING IN SIGNIFICANTLY INCREASED RISK OF INJURY OR DEATH.
Remedy: CHRYSLER WILL REPLACE THE LIFTGATE LATCH WITH A NEW STRONGER LATCH ASSEMBLY WITHOUT CHARGE. CHRYSLER BEGAN NOTIFYING OWNERS DURING DECEMBER 1995.
Component: AIR BAGS
VEHICLE DESCRIPTION: MINI VANS. THE WIRING THAT INITIATES THE DRIVER AND/OR PASSENGER AIR BAG COULD ELECTRICALLY SHORT CIRCUIT TO GROUND. A SHORT CIRCUIT TO GROUND THAT EXISTS IMMEDIATELY AFTER TURNING THE IGNITION KEY TO THE "ON" OR "START" POSITION CAN CAUSE THE AIR BAG(S) TO INADVERTENTLY DEPLOY.
Consequence: INADVERTENT AIR BAG DEPLOYMENT CAN INJURE A FRONT SEAT OCCUPANT.
Remedy: DEALERS WILL PERFORM AN ELECTRONIC DIAGNOSTIC CHECK. ANY SHORT CIRCUITS IDENTIFIED IN EITHER THE DRIVER'S OR PASSENGER SIDE AIR BAG INITIATOR WIRE CIRCUIT WILL BE REPAIRED.
Component: LATCHES/LOCKS/LINKAGES:HATCHBACK/LIFTGATE:LOCK
VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER MINIVANS WITHOUT REMOTE RELEASE. THIS IS NOT A SAFETY RECALL. THERE HAS BEEN NO DETERMINATION THAT A SAFETY DEFECT EXISTS WITH THE MINIVAN LATCHES. CHRYSLER IS CONDUCTING A SERVICE CAMPAIGN TO REPLACE THE LIFTGATE LATCH ASSEMBLY OF THE AFFECTED MINIVANS. IN A COLLISION, THE REAR LIFTGATE LATCH ASSEMBLY COULD OPEN.
Consequence: IF THE LIFTGATE LATCH OPENS, OCCUPANTS CAN BE EJECTED RESULTING IN SIGNIFICANTLY INCREASED RISK OF INJURY OR DEATH.
Remedy: CHRYSLER DEALERS WILL REPLACE THE LIFTGATE LATCH WITH A NEW STRONGER LATCH ASSEMBLY WITHOUT CHARGE. CHRYSLER BEGAN NOTIFYING OWNERS OF THESE VEHICLES BEGINNING SEPTEMBER 1995.
1994 DODGE CARAVAN GAS TANK LEAK. THE CONSUMER STATED SHE WAS SEARCHING FOR INFORMATION REGARDING A GAS LEAK AND CAME ACROSS RECALL 99V216000 AND WAS WONDERING IF IT APPLIED TO HER VEHICLE? AND IF SO, WILL DODGE HONOR THE RECALL AND FIX HER VEHICLE?
WENT TO WORK ON APRIL 1, 2009 HAD BRAKES, WHEN I WENT TO GO HOME THE BRAKES WENT ALL THE WAY TO THE FLOOR, AND ANTI BRAKE LIGHT CAME ON, CHANGED FRONT BRAKES , DID NOT NEED IT , BUT DID IT ANYWAY, WAS GOING TO CHANGE THE BACK BUT THEY DID NOT NEED IT, BLED THE BRAKES, ALL WORKED FINE , THEN WENT OKLAHOMA APRIL 11TH , STAYED IN MOTEL AND BRAKES WHERE FINE, GOT UP NEXT MORNING AND WENT TO DO SOME THINGS AND AGAIN THE BRAKES WENT ALL THE WAY TO THE FLOOR AND ABS LIGHT COMES ON ,STILL HAS PLENTY OF FLUID. *TR
HAVE GEN 3 SEATBELT, UNSAFE, COULD UNLATCH IN A CAR ACCIDENT. CAN ALSO BE PUSHED INTO A FALSE HOLE CAUSING A FALSE LATCH. *TR
I TRIED TO OPEN THE HOOD OF MY MINIVAN AND THE RELEASE BROKE OFF. THE RELEASE WAS ON THE INSIDE OF THE 1994 DODGE MINIVAN AND I DON'T KNOW WHAT CAUSED IT TO BREAK OFF. I'VE CHECKED THE SAFETY DEFECT NOTIFICATIONS FOR "1994 DODGE MINIVANS" AND COULD NOT FIND ANY OTHER MENTIONS OF FAILURE OF THE HAND RELEASE FOR THE VEHICLES' HOODS. *TR
REAR WINDOW ON LIFT GATE SHATTERED IN A THOUSAND PIECES FOR NO REASON WHILE PARKED (GLASS INSIDE AND OUTSIDE). OUTSIDE TEMP WAS ABOUT 20 F AND CLOUDY. GLASS TYPE IS A PRIVACY TINTED WITH WINDOW DEFROSTER. IT APPEARS GLASS WAS NOT REQUIRED TO BE A SAFETY GLASS TYPE AS COMPARED TO A WINDSHIELD WITH A "PLASTIC SANDWICH IN-BETWEEN. ABOUT 10 HOURS OF CLEAN UP REQUIRED. MANY SMALL GLASS FRAGMENTS AND "GLASS DUST" TRAVELED AS FAR AS THE FRONT DASHBOARD. OWNER WILL BE REPLACING GLASS. COST ESTIMATED TO BE BETWEEN $300 TO $400 PARTS AND LABOR. I HAVE PICTURES AVAILABLE IF NEEDED .*CN
SERPENTINE BELT COMES OFF...DRY, WET, SNOW..BIG, LITTLE ...LITERALLY NO PUDDLES...AND THE GATORBACK BELT DOESN'T FIX IT, NOR THE SNOW SHIELD ON THE PULLEY SHIELD.....WITH ALL THE COMPLAINTS AND THE NUMEROUS TIMES MY BELT HAS COME OFF..YOU'D THINK CHRYSLER WOULD HAVE FIXED THIS LONG AGO...NO JUST SOAK PEOPLE FOR MONEY..IF THEY R NOT MECHANICALLY INCLINED( WHICH THANKS TO MY FATHER, BROTHER, AND HUSBAND) I AM.....AND I KNOW ABOUT THE INTERNET SITE FORUMS THAT HELP EACH OTHER OUT...IN TIMES LIKE THESE. SOME UNFORTUNATELY..SEVERAL HUNDREDS AND THOUSANDS OF DOLLARS LATER...HOW UNFAIR OF CHRYSLER...AND WE'RE TALKING.... THIS PROBLEM HAS BEEN AROUND AWHILE...YOU'D HAVE THOUGHT THEY WOULD'VE FIXED IT LONG AGO ..EVEN BEFORE PUTTING OUT NEW ONES WITH THE SAME PROBLEM....I BET THOSE NEW BUYERS ARE FIT TO BE TIED RIGHT ABOUT NOW!!!! HOPEFULLY ALL THESE COMPLAINTS AND I HOPE YOU PEOPLE ARE COMPLAINING...GETS SOMETHING DONE!! *NM
1994 DODGE CARAVAN MILEAGE 66.873 WITH WHEELCHAIR LIFT REAR LIFTGATE HINGE, BOLT HOLDING THE HINGE TOGETHER BROKE DUE TO METAL FATIGUE, LETTING HINGE SEPARATE, CAUSING LIFTGATE TO DROP DOWN. THIS IS A VERY SERIOUS SAFETY PROBLEM. CHRYSLER/DODGE 1-800-992,1997 REF.#15261363 WAS CONTACTED BY PHONE SEVERAL TIMES. I WAS TOLD THAT II WAS NOT ON THE RECALL LIST. SORRY CAR IS OUT OF WARRANTY. THE VAN IS ALWAYS PARKED IN MY CARRAGE. LIKE NEW. I HAVE THE OLD PARTS AND 17 COLOR POCTURES. *JB
LACKS POWER, WANTS TO STALL LIKE IT'S NOT GETTING ANY FUEL, HAVE REPLACED NUMEROUS PARTS INCLUDING WHAT WAS LISTED ON THE DIAGNOSTIC SCANS, CLUNKING NOISE UNDER VAN. NOTHING SEEMS TO CORRECT THE PROBLEM. HAVE SPENT OVER $600 IN PARTS ALONE, NOT COUNTING LABOR. *NM
DT: CONSUMER STATES HIS 1994 DODGE CARAVAN THAT HE PURCHASED USED ABOUT 8 MONTHS AGO HAD TRANSMISSION PROBLEMS IMMEDIATELY. THE TRANSMISSION WILL POP OUT OF GEAR WHEN IT IS HOT. THE VEHICLE HAS TO BE SHUT OFF AND THEN IT WILL START AGAIN. THE FIRST TIME IT HAPPENED, SEPTEMBER 2004, HE TOOK THE VEHICLE TO A DEALERSHIP AND WAS TOLD THAT THEY COULD NOT DUPLICATE THE PROBLEM. IT HAPPENED AGAIN ABOUT 30 DAYS AGO AND HAPPENED AGAIN YESTERDAY. *JB
WHILE STOPPED AT A LIGHT, ANOTHER VEHICLE REAR ENDED THE CONSUMER. THE CONSUMER PROCEEDED TO STRIKE THE VEHICLE IN THE FRONT OF HIM. BOTH PASSENGER AND DRIVER SEATS COLLAPSED. THE DRIVER SEAT FELL ONTO THE CHILD PASSENGER, BREAKING SEVERAL BONES IN HIS FACE AND HAD TO UNDERGO SURGERY. *JB
NHTSA RECALL CAMPAIGN 99V213000, THE BOLT TO THE HATCH BROKE, CAUSING THE PISTON TO BREAK IN HALF. A STICK MUST BE USED TO HOLD THE HATCH UP. CONSUMER WAS AWARE OF RECALL FOR THIS PARTICULAR MODEL. *AK
THE SERPENTINE BELT CONTINUOUSLY SLIPS OFF WHICH CAUSES THE STEERING TO BECOME INOPERABLE. THE POWER STEERING COMPLETELY FAILS. *AK
Showing 15 of 772 complaints