Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2003 Hyundai Sonata.
| Trim | City | Hwy | Combined | Annual fuel $ |
|---|---|---|---|---|
| 2.4L 4 cyl Automatic 4-spd | 19 | 28 | 22 | $2,700 |
| 2.7L 6 cyl Automatic 4-spd | 17 | 25 | 20 | $3,000 |
| 2.4L 4 cyl Manual 5-spd | 20 | 28 | 23 | $2,600 |
| 2.7L 6 cyl Manual 5-spd | 18 | 25 | 20 | $3,000 |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: SUSPENSION
HYUNDAI IS RECALLING 188,282 MY 2001-2004 SONATA AND MY 2001-2004 XG300 AND XG350 VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE JURISDICTIONS DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUB-FRAME ON THE VEHICLES, AND MAY RESULT IN THINNING OR PERFORATION OF THE SUB-FRAME STEEL. THE CORROSION IS FREQUENTLY VISIBLE AND OFTEN DISCOVERED DURING INSPECTION OR ROUTINE MAINTENANCE, AND OWNERS MAY ALSO HEAR NOISES OR NOTICE TIRE MISALIGNMENT AND STEERING PULL. IF THESE SIGNALS ARE UNDETECTED OR UNHEEDED, THE CORROSION MAY PROGRESS AND THE FORWARD MOUNTING OF THE LOWER CONTROL ARM MAY DETACH FROM THE SUB-FRAME.
Consequence: IF THAT HAPPENS, THE VEHICLE MAY LOSE DRIVE POWER TO THE WHEELS, AND THE FRONT WHEEL MAY MAKE CONTACT WITH THE FENDER OR WHEEL WELL, THEREBY INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL MEASURE THE THICKNESS OF THE FRONT SUB-FRAME AND INSPECT THE FRONT SUB-FRAME FOR CORROSION DAMAGE AND, IF NECESSARY, THE FRONT SUB-FRAME WILL BE REPLACED WITH A NEW SUB-FRAME THAT INCORPORATES ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT SUB-FRAME DOES NOT REQUIRE REPLACEMENT, THE DEALER WILL ADD DRAINAGE HOLES TO THE SUB-FRAME AND WILL TREAT THE SUB-FRAME WITH RUST-PROOFING MATERIAL TO STOP THE CORROSION PROCESS. THIS PROCEDURE WILL BE PERFORMED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Component: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
HYUNDAI IS RECALLING 91,350 MY 2002-2003 HYUNDAI SONATA VEHICLES. REPEATED USE OF THE INTERIOR DOOR HANDLE MAY CAUSE WEAR OF THE CHROME PLATE. IF THE TOP EDGE OF THE HANDLE HAS VERY THIN CHROME PLATING, THAT PORTION OF THE PLATING MAY WEAR AWAY MORE EASILY THAN MORE THICKLY PLATED AREAS AS THE DOOR HANDLE IS USED. THE WORN CHROME PLATING ON THE UPPER EDGE OF THE HANDLE MAY RESULT IN A CRACK OR SEPARATION BETWEEN THE CHROME PLATING ON THE INBOARD AND OUTBOARD SURFACES OF THE HANDLE, WHICH MAY FORM A SHARP EDGE.
The contact owns a 2003 Hyundai Sonata. The contact stated that upon taking the vehicle to an independent mechanic, the mechanic discovered severe corrosion on the suspension. Upon investigation, the contact discovered NHTSA Campaign Number: 09V124000 (Suspension). The vehicle was taken to a dealer, and the contact was informed that due to the severe corrosion, the recall repair could not be performed. The mechanic at the dealer described the vehicle as being unsafe to drive. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 58,000
NHTSA Campaign ID Number: 09V124000 NHTSA Action Number: EA08016 Recall calls for repair or replacement of front sub-frame, due to corrosion. Local dealer responded, “ . . . we will not be able to perform recall”. I was told the corrosion was too far gone to repair. They refuse to replace the defective part.
The contact owns a 2003 Hyundai Sonata. The contact stated that while the vehicle was being serviced by an independent mechanic, the mechanic informed the contact that the front subframe was severely corroded. The mechanic determined that the failure was related to a recall. The vehicle was taken to the dealer, where the contact was informed that the subframe needed to be replaced; however, the repair could not be covered under NHTSA Campaign Number: 09V124000 (Suspension) because the parts had been discontinued. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was unknown. Parts distribution disconnect.
The 2003 Hyundai Sonata has 6 NHTSA recalls and 198 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Consequence: THIS MAY INFLICT LACERATION INJURIES TO ANYONE USING THE DOOR HANDLE.
Remedy: DEALERS WILL REPAIR THE CHROME PLATED INTERIOR DOOR HANDLE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2009. OWNERS MAY CONTACT HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Component: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
HYUNDAI IS RECALLING 82 MODEL YEAR 2002-2003 SONATA VEHICLES. REPEATED USE OF THE INTERIOR DOOR HANDLE MAY CAUSE WEAR OF THE CHROME PLATING. IF THE TOP EDGE OF THE HANDLE HAS VERY THIN CHROME PLATING THAT PORTION OF THE PLATING MAY WEAR AWAY MORE EASILY THAN MORE THICKLY PLATED AREAS AS THE DOOR HANDLE IS USED. THE WORN CHROME PLATING ON THE UPPER EDGE OF THE HANDLE MAY RESULT IN A CRACK OR SEPARATION BETWEEN THE CHROME PLATING ON THE INBOARD AND OUTBOARD SURFACES OF THE HANDLE, WHICH MAY FORM A SHARP EDGE.
Consequence: A SHARP EDGE COULD LACERATE OR OTHERWISE INJURE A VEHICLE OCCUPANT.
Remedy: DEALERS WILL REPAIR THE CHROME PLATED INTERIOR DOOR HANDLE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 16, 2009. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO AT 1-787-999-3333.
Component: TIRES:TEMPORARY/EMERGENCY SPARE TIRE
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A TRACTION CONTROL SYSTEM (TCS), IF THE T125/70D-15 COMPACT SPARE TIRE IS INSTALLED ON A FRONT WHEEL POSITION, THE TCS MAY INADVERTENTLY ACTIVATE BEGINNING AT SPEEDS OF 20 MPH.
Consequence: INADVERTENT ACTIVATION OF THE TCS WILL CAUSE AUTOMATIC APPLICATION OF THE BRAKE AT THE WHEEL WHERE THE COMPACT SPARE TIRE IS INSTALLED. INADVERTENT BRAKE APPLICATION COULD CAUSE OVERHEATING AND DAMAGE TO THE BRAKE, AND MAY PREVENT THE VEHICLE FROM BEING DRIVEN AT SPEEDS ABOVE 20 MPH, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE SPARE TIRE WITH A NEW LARGER DIAMETER T125/80R-15 COMPACT SPARE TIRE AND A NEW TIRE PRESSURE LABEL WILL BE INSTALLED ON THE DRIVER'S DOOR TO PROVIDE INFORMATION APPLICABLE TO THE T125/80R-15 COMPACT SPARE TIRE. VEHICLES PRODUCED FROM NOVEMBER 15, 2002 THROUGH DECEMBER 16 2002, ALREADY CONTAIN T125/80R-15 COMPACT SPARE TIRES, WILL ONLY REQUIRE NEW TIRE PRESSURE LABELS. OWNER NOTIFICATION BEGAN JUNE 30, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Component: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
SOME PASSENGER VEHICLES CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.
Consequence: FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN ON JUNE 30, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Component: FUEL SYSTEM, GASOLINE:STORAGE
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY" A VALVE ON THE FUEL TANK ASSEMBLY MAY NOT CLOSE PROPERLY. IF A VEHICLE ROLLS OVER AND THE FUEL TANK ASSEMBLY VALVE IS NOT PROPERLY CLOSED, FUEL SPILLAGE MAY OCCUR.
Consequence: FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
The contact owns a 2003 Hyundai Sonata. The contact stated that while self-inspecting the vehicle, he noticed that the subframe was extremely rusted. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 69,425. The contact stated that no assistance has been offered from the dealership from which the vehicle was purchased from.
Airbag light came on and stays on. Pulled a code that pointed to the wiring in the passenger seat. Moved wiring around and made sure connectors were properly plugged and the light went away for maybe a week. Light is back on again. Removed seat bolts to gain better access, used tubing and electrical tape to straighten any kinked wiring I could find underneath passenger front seat, disconnected and reconnected connections. Airbag light blinked once and still remains on with the code still pointing to the passenger seat wiring. Apparently this issue has been reported many times in online forums with no meaningful response from the company though this clearly affects proper airbag deployment.
TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, WHEN THE VEHICLE LOSS MOTIVE POWER AND STALLED. THE CONTACT PUSHED THE VEHICLE TO THE SIDE OF THE ROADWAY. THE CONTACT HAD THE VEHICLE TOWED TO A CERTIFIED MECHANIC WHO DIAGNOSED THAT CRANKSHAFT POSITION SENSOR AND THE CRANKSHAFT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 45,922. THE VIN WAS NOT AVAILABLE.*DT*JB
YOU CAN NOT FILL GAS TANK PASS HALF WITH OUT THE SMELL FILLING THE CAR .THE BACK SUSPENSION WHEN YOU GO OVER 40 TALES FROM SIDE TO SIDE .THE CAR WAS ON THE HIGHWAY .
TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING INSPECTED BY AN INDEPENDENT MECHANIC, SHE WAS INFORMED THERE WAS CORROSION TO THE VEHICLE'S SUBFRAME. THE CONTACT WAS ALSO INFORMED THAT THE FRONT PASSENGER'S SIDE SWAY BAR LINKAGE AND BOTH FRONT WHEEL BEARINGS NEEDED TO BE REPLACED. A DEALER WAS NOT NOTIFIED OF FAILURE. THE VEHICLE HAD NOT BEEN DIAGNOSED NOR REPAIRED AS OF YET. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 09V124000 (SUSPENSION) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS INFORMED OF THE FAILURE AND A COMPLAINT WAS FILED. THE FAILURE MILEAGE WAS 184,077.
AIR BAG WARNING LIGHT IS ON. WHEN RESET THE LIGHT COMES ON AGAIN.
AIRBAG LIGHT IS ON BUT THEY HAVE NOT DEPLOYED & NO APPARENT DAMAGE TO THE AIRBAG SYSTEM, WIRING, ETC. WILL NOT PASS INSPECTION WITH THE ABS LIGHT ON, AS YOU WELL KNOW.
TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. WHILE DRIVING 30 MPH, THE VEHICLE BEGAN TO VEER TO THE RIGHT WITHOUT WARNING AND THE POWER STEERING FAILED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRONT SUBFRAME WAS CORRODED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS 117,000.
THE AIR BAG LIGHT IS CONSTANTLY ON, MEANING THAT IN THE EVENT OF AN ACCIDENT, THEY WILL NOT DEPLOY. INCREDIBLY DANGEROUS. THIS IS APPARENTLY DUE TO WIRING UNDERNEATH THE PASSENGER SEAT STRETCHING AND PINCHING FROM MOVING THE SEAT ITSELF AND WHEN THINGS ARE PLACED UNDERNEATH THE SEAT THAT MAY DISTURB THE WIRING. I KNOW IT IS THE WIRING UNDERNEATH THE PASSENGER SEAT DUE TO CHECKING THE TROUBLE CODE AND ALSO BEING ABLE TO TEMPORARILY FIX THE ISSUE FOR A COUPLE WEEKS BY GINGERLY MOVING THE WIRES UNTIL THE LIGHT WENT AWAY. NOW I CAN'T GET THE LIGHT TO GO AWAY NO MATTER WHAT METHODS I TRY. CAN'T FIND A REPLACEMENT SET OF WIRES NOR CAN I LOCATE WHICH WIRE SPECIFICALLY IS BEING AFFECTED TO TRY TO FIX THE ISSUE MYSELF. I HAVE SEEN DOZENS OF PEOPLE MAKING THIS SAME COMPLAINT ABOUT THE AIRBAG LIGHT STAYING ON. THIS NEEDS A RECALL SINCE THIS CAN EASILY LEAD TO DEATH SINCE THE AIRBAG WILL NOT DEPLOY TO ATTEMPT SAVING METHODS TO PASSENGERS. LIGHT WAS ON FOR THE PREVIOUS OWNER FOR I DON'T KNOW HOW LONG AND HAS BEEN ON FOR ME FOR ALMOST A YEAR NOW.
TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 10 MPH, THERE WAS SMOKE EMITTING FROM THE FRONT OF THE VEHICLE. IN ADDITION, THERE WAS AN ABNORMAL ODOR OF FUEL INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FAILURE COULD NOT BE DETERMINED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V178000 (FUEL SYSTEM, GASOLINE). A LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000. *TT *TR
TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. THE CONTACT STATED THAT THE VEHICLE FAILED TO START WHEN ATTEMPTED TO DRIVE. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED ONCE. THE VEHICLE WAS TAKEN TO POTAMKIN HYUNDAI (6200 NW 167TH ST, MIAMI LAKES, FL 33014, PHONE: (305) 728-5030), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 139,000.
THE BRAKE PEDAL DROPS DURING BRAKING WITH A CLUNK. THE BRAKES ARE WEAK AT THAT POINT BUT RECOVER. I REPLACED THE BRAKE PADS AND ROTORS AND MASTER CYLINDER, STILL THE SAME PROBLEM. IT HAPPENS A LOT. MY WIFE WON'T DRIVE THE CAR ANYMORE.
Showing 15 of 198 complaints