Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2002 Hyundai Sonata.
| Trim | City | Hwy | Combined | Annual fuel $ |
|---|---|---|---|---|
| 2.4L 4 cyl Automatic 4-spd | 19 | 27 | 22 | $2,700 |
| 2.7L 6 cyl Automatic 4-spd | 18 | 25 | 20 | $3,000 |
| 2.4L 4 cyl Manual 5-spd | 20 | 28 | 23 | $2,600 |
| 2.7L 6 cyl Manual 5-spd | 18 | 25 | 20 | $3,000 |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: SUSPENSION
HYUNDAI IS RECALLING 188,282 MY 2001-2004 SONATA AND MY 2001-2004 XG300 AND XG350 VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE JURISDICTIONS DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUB-FRAME ON THE VEHICLES, AND MAY RESULT IN THINNING OR PERFORATION OF THE SUB-FRAME STEEL. THE CORROSION IS FREQUENTLY VISIBLE AND OFTEN DISCOVERED DURING INSPECTION OR ROUTINE MAINTENANCE, AND OWNERS MAY ALSO HEAR NOISES OR NOTICE TIRE MISALIGNMENT AND STEERING PULL. IF THESE SIGNALS ARE UNDETECTED OR UNHEEDED, THE CORROSION MAY PROGRESS AND THE FORWARD MOUNTING OF THE LOWER CONTROL ARM MAY DETACH FROM THE SUB-FRAME.
Consequence: IF THAT HAPPENS, THE VEHICLE MAY LOSE DRIVE POWER TO THE WHEELS, AND THE FRONT WHEEL MAY MAKE CONTACT WITH THE FENDER OR WHEEL WELL, THEREBY INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL MEASURE THE THICKNESS OF THE FRONT SUB-FRAME AND INSPECT THE FRONT SUB-FRAME FOR CORROSION DAMAGE AND, IF NECESSARY, THE FRONT SUB-FRAME WILL BE REPLACED WITH A NEW SUB-FRAME THAT INCORPORATES ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT SUB-FRAME DOES NOT REQUIRE REPLACEMENT, THE DEALER WILL ADD DRAINAGE HOLES TO THE SUB-FRAME AND WILL TREAT THE SUB-FRAME WITH RUST-PROOFING MATERIAL TO STOP THE CORROSION PROCESS. THIS PROCEDURE WILL BE PERFORMED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Component: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
HYUNDAI IS RECALLING 91,350 MY 2002-2003 HYUNDAI SONATA VEHICLES. REPEATED USE OF THE INTERIOR DOOR HANDLE MAY CAUSE WEAR OF THE CHROME PLATE. IF THE TOP EDGE OF THE HANDLE HAS VERY THIN CHROME PLATING, THAT PORTION OF THE PLATING MAY WEAR AWAY MORE EASILY THAN MORE THICKLY PLATED AREAS AS THE DOOR HANDLE IS USED. THE WORN CHROME PLATING ON THE UPPER EDGE OF THE HANDLE MAY RESULT IN A CRACK OR SEPARATION BETWEEN THE CHROME PLATING ON THE INBOARD AND OUTBOARD SURFACES OF THE HANDLE, WHICH MAY FORM A SHARP EDGE.
I purchased a 2002 Hyundai Sonata from a private seller who represented the car had about 40,000–45,000 miles. However, diagnostics from O’Reilly Auto Parts showed 278,000 miles, and Hyundai’s system confirmed over 302,000 miles. The title is marked “mileage exempt,” and the seller is not the same person listed on the title, suggesting title jumping. I have repair invoices, diagnostic records, and screenshots of the original advertisement. I believe this constitutes odometer tampering and misrepresentation.
The contact owns a 2002 Hyundai Sonata. The contact stated that while his girlfriend was driving at a slow speed, the sub frame snapped and fractured the axle. The vehicle was towed to an independent mechanic, and the contact was made aware of NHTSA Campaign Number: 09V124000 (Suspension). The vehicle was towed to the local dealer, who confirmed that the part had been discontinued. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that the part had been discontinued. No additional assistance was provided. The failure mileage was approximately 86,000.
The contact owns a 2002 Hyundai Sonata. The contact stated while driving approximately 15 MPH and slowing for a right turn, the contact heard an abnormal popping sound coming from the front end of the vehicle. The contact was in the middle of the turn when the vehicle lost motive power. The contact stated that the engine was still running, but the vehicle was not responding as needed. The contact turned off the vehicle and observed that the passenger’s side control arm had detached and fallen onto the street. The contact had the vehicle towed to an independent mechanic. The vehicle was diagnosed, and it was determined that the entire front end was extremely corroded. The contact was informed that the vehicle was not drivable. The vehicle was not repaired. The manufacturer was not informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 09V124000 (Suspension). The failure mileage was approximately 204,000.
The 2002 Hyundai Sonata has 7 NHTSA recalls and 325 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Consequence: THIS MAY INFLICT LACERATION INJURIES TO ANYONE USING THE DOOR HANDLE.
Remedy: DEALERS WILL REPAIR THE CHROME PLATED INTERIOR DOOR HANDLE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2009. OWNERS MAY CONTACT HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Component: AIR BAGS:SIDE/WINDOW
ON CERTAIN PASSENGER VEHICLES, THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) SIDE IMPACT AIR BAG SATELLITE SENSORS MAY BE TOO SENSITIVE TO SOME LATERAL ACCELERATIONS THAT ARE NOT CAUSED BY SIDE IMPACTS TO THE VEHICLE, SUCH AS FORCEFULLY SLAMMING A DOOR CLOSED.
Consequence: INADVERTENT DEPLOYMENT OF A SRS SIDE IMPACT AIR BAG WHEN A SIDE IMPACT CRASH HAS NOT OCCURRED COULD INCREASE THE RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG SATELLITE SENSORS. OWNER NOTIFICATION BEGAN JULY 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Component: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
HYUNDAI IS RECALLING 82 MODEL YEAR 2002-2003 SONATA VEHICLES. REPEATED USE OF THE INTERIOR DOOR HANDLE MAY CAUSE WEAR OF THE CHROME PLATING. IF THE TOP EDGE OF THE HANDLE HAS VERY THIN CHROME PLATING THAT PORTION OF THE PLATING MAY WEAR AWAY MORE EASILY THAN MORE THICKLY PLATED AREAS AS THE DOOR HANDLE IS USED. THE WORN CHROME PLATING ON THE UPPER EDGE OF THE HANDLE MAY RESULT IN A CRACK OR SEPARATION BETWEEN THE CHROME PLATING ON THE INBOARD AND OUTBOARD SURFACES OF THE HANDLE, WHICH MAY FORM A SHARP EDGE.
Consequence: A SHARP EDGE COULD LACERATE OR OTHERWISE INJURE A VEHICLE OCCUPANT.
Remedy: DEALERS WILL REPAIR THE CHROME PLATED INTERIOR DOOR HANDLE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 16, 2009. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO AT 1-787-999-3333.
Component: TIRES:TEMPORARY/EMERGENCY SPARE TIRE
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A TRACTION CONTROL SYSTEM (TCS), IF THE T125/70D-15 COMPACT SPARE TIRE IS INSTALLED ON A FRONT WHEEL POSITION, THE TCS MAY INADVERTENTLY ACTIVATE BEGINNING AT SPEEDS OF 20 MPH.
Consequence: INADVERTENT ACTIVATION OF THE TCS WILL CAUSE AUTOMATIC APPLICATION OF THE BRAKE AT THE WHEEL WHERE THE COMPACT SPARE TIRE IS INSTALLED. INADVERTENT BRAKE APPLICATION COULD CAUSE OVERHEATING AND DAMAGE TO THE BRAKE, AND MAY PREVENT THE VEHICLE FROM BEING DRIVEN AT SPEEDS ABOVE 20 MPH, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE SPARE TIRE WITH A NEW LARGER DIAMETER T125/80R-15 COMPACT SPARE TIRE AND A NEW TIRE PRESSURE LABEL WILL BE INSTALLED ON THE DRIVER'S DOOR TO PROVIDE INFORMATION APPLICABLE TO THE T125/80R-15 COMPACT SPARE TIRE. VEHICLES PRODUCED FROM NOVEMBER 15, 2002 THROUGH DECEMBER 16 2002, ALREADY CONTAIN T125/80R-15 COMPACT SPARE TIRES, WILL ONLY REQUIRE NEW TIRE PRESSURE LABELS. OWNER NOTIFICATION BEGAN JUNE 30, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Component: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
SOME PASSENGER VEHICLES CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.
Consequence: FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN ON JUNE 30, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Component: FUEL SYSTEM, GASOLINE:STORAGE
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY" A VALVE ON THE FUEL TANK ASSEMBLY MAY NOT CLOSE PROPERLY. IF A VEHICLE ROLLS OVER AND THE FUEL TANK ASSEMBLY VALVE IS NOT PROPERLY CLOSED, FUEL SPILLAGE MAY OCCUR.
Consequence: FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
The contact owns a 2002 Hyundai Sonata. The contact stated while driving at an undisclosed speed, the vehicle was shaking and made abnormal sounds. The vehicle then lost motive power. The vehicle was towed to an independent mechanic who diagnosed that the failure was related to NHTSA Campaign Number: 09V124000 (Suspension) however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 145,000.
Made right hand turn passenger wheel cocked dead stop. When checked out was told sub frame rust apart on passenger side.
YOU DID A RECALL A NUMBER OF YEARS AGO ON THE CHROME ON THE INTERIOR DOOR HANDLES PEELING OFF AND BEING HAZARDOUS. NOW THE SAME THING IS HAPPENING TO THE CHROME ON THE GEAR SHIFT HANDLE. IT IS VERY SHARP AND HAS MADE MINOR CUTS TO THE RIGHT HAND WHILE SHIFTING THE VEHICLE. THE VEHICLE WAS STATIONARY. IT IS AN ONGOING PROBLEM AS THE CHROME KEEPS PEELING OFF A LITTLE AT A TIME.
ON NOVEMBER 30, 2020 AFTER SHOPPING IN FOOD STORE, STARTING THE CAT AND COMING OUT OF A PARKING LOT AND DRIVING THE CAR FORWARD, I SMELL SOMETHING BURNING. STOP & OPEN THE FRONT HOOD AND SAW SMOKE COMING OUT OF THE AIR FILTER HOUSING AND STARTED TO BURN. SOMEBODY HELPED AND PUT OUT THE FIRE WITH A FIRE EXTINGUISHER. THE CAR WAS RUNNING HOOD AND MY DAILY DRIVER BEFORE THE INCIDENT.
REAR SUBFRAME RUSTED AWAY AND TRAILING ARMS BOTH FELL OFF. WAS TRAVELING AND WHEN I WAS MAKING A LEFT TURN THE RIGHT TRAILING ARM BROKE OFF AND INSTANTLY MADE THE CAR ALMOST SWERVE OFF THE ROAD. I CONTINUED HOME A BLOCK FURTHER AND LOOKED TO SEE THE DAMAGE. RIGHT SIDE TRAILING ARM COMPLETELY DETACHED AND THE LEFT SIDE BARELY HANGING ON. SENT TO HYUNDAI TO HAVE LOOKED AT AND GIVEN A QUOTE. NOTHING YET...
MY ROOMMATE GOT INTO A T BONE TYPE ACCIDENT SHE WAS GOING AT LEAST 25MPH AND THE AIR BAG DID NOT DEPLOY BUT IT HIT HARD ENOUGH TO RIP THE CORE SUPPORT OFF, WE HAVE PICTURES. SHE DID NOT TAKE THE AMBULANCE BUT SHE'S WILL PROBABLY GO TO THE ER LATER
TL* THE CONTACT OWNS A 2002 HYUNDAI SONATA. WHILE EXITING THE FREEWAY AT APPROXIMATELY 45 MPH, THE PASSENGER SIDE AXLE FAILED AND DAMAGED THE WHEEL WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FRONT SUSPENSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS ALSO TOWED TO MALLOY HYUNDAI (1880 OPITZ BLVD, WOODBRIDGE, VA 22191, (703) 490-8170) FOR ANOTHER DIAGNOSTIC TEST, BUT THE RESULTS WERE NOT YET AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS APPROXIMATELY 155,000.
GAS TANK WILL NOT NORMALLY ACCEPT GAS AND CLICKS OFF EVERY 5 CENTS WORTH THAT IS PUMPED. AFTER 3 GALLONS AND 15 MINUTES LATER, THE TANK SPITS OUT THE GAS. THIS PROBLEM IS SO CHRONIC THE ATTENDANTS AT COSTCO GAS TOLD ME MANY SONATAS HAVE THIS ISSUE. RECALL OR CLASS ACTION LAWSUIT?
I PURCHASED THIS 2002 HYUNDAI SONATA AND HAD IT INSPECTED IN PENNSYLVANIA, THE VEHICLE FAILS DUE TO ROTTED/RUSTED OUT FRONT SUBFRAME, THIS COMPONENT WAS SUPPOSED TO BE REPLACED UNDER RECALL NHTSA CAMPAIGN ID NUMBER : 09V124000, MANUFACTURER CAMPAIGN NUMBER: 089 HOWEVER HYUNDAI SAID IT WAS INSPECTED AND RECALL WAS CLOSED.
TL* THE CONTACT OWNS A 2002 HYUNDAI SONATA. WHILE DRIVING APPROXIMATELY 5 MPH, THE ENGINE FELL THROUGH THE CRADLE ASSEMBLY AND CRUSHED THE AXLE. THERE WAS NO WARNING INDICATOR ILLUMINATED. PRIOR TO THE FAILURE, THE CONTACT HEARD A LOT OF SQUEAKING WHILE DRIVING VARIOUS SPEEDS AND MAKING TURNS. THE DEALER WAS NOT CALLED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 155,000.
TL* THE CONTACT OWNS A 2002 HYUNDAI SONATA. WHILE MAKING A RIGHT TURN, THE CONTACT HEARD AN ABNORMAL NOISE UNDERNEATH THE VEHICLE. THE CONTACT STATED THAT THE VEHICLE STARTED TO WOBBLE AND THEN STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SUBFRAME WAS CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT CALLED LANCASTER HYUNDAI AT (866) 528-2534 (LOCATED AT 5260 MAIN ST, EAST PETERSBURG, PA 17520) AND WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ALSO INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 127,028.
PAINT IS FLAKING OFF OF ALL THE DOOR HANDLES ON MY 2001 SONATA GOLD COLOR. WHEN IT WAS ONLY HAPPENING ON ONE DOOR, MY DEALER SAID IT WAS NOT THERE PROBLEM. NOW THAT IT IS HAPPENING ON ALL OF THEM, IT IS OBVIOUS TO ME THAT IT IS A DEFECT. HAS ANYONE ELSE HAD THIS PROBLEM AND COULD THEY GET IT RESOLVED?
Showing 15 of 325 complaints