Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2004 Mazda Mpv.
| Trim | City | Hwy | Combined | Annual fuel $ |
|---|---|---|---|---|
| 3.0L 6 cyl Automatic 5-spd | 16 | 23 | 18 | $3,300 |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Mazda North America Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2006-2007 Mazdaspeed6 and 2004 MPV vehicles nationwide. Mazda is also recalling 2005-2006 MPV vehicles in Alabama, Arizona, Arkansas, California, Delaware, the District of Columbia, Florida, Georgia, Hawaii, Illinois, Indiana, Kansas, Kentucky, Louisiana, Maryland, Mississippi, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, South Carolina, Tennessee, Texas, Virginia, West Virginia, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. On July 9, 2019 this recall was expanded to include certain 2004-2011 RX-8 vehicles that were previously recalled under 16V-354 but have not yet been repaired. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate inflator, free of charge. The recall began July 6, 2018. Mailing to the affected RX-8 owners began July 6, 2019. Owners may contact Mazda customer service at 1-800-222-5500, option 4. Mazda's number for this recall is 2618F. Note: With the addition of the RX-8 vehicles, this recall fully supersedes recall 16V354.
2004 MAZDA MPV. CONSUMER WRITES ASKING TO BE REMOVED FROM RECALL LIST BECAUSE THEY NO LONGER OWN THE VEHICLE.
FRONT CROSS MEMBER CORROSION; FRAME DAMAGED; CAR DANGEROUSLY UNSTABLE. WHEEL ALIGNMENT COST ME $72.64 AND FRAME REPAIR COST $693.36. THE VEHICLE IN THE SHOP FOR 4 DAYS. MENTAL ANGUISH. MAZDA DEALER DECLINED REPAIRS. MAZDA CUSTOMER SERVICE DECLINED TO PAY. NOW THEY ARE ADMITTING THAT PROBLEM ON MAZDA 6 VEHICLES. IT'S AN OLD PROBLEM PROBABLY RELATED TO METALLURGY OR IMPROPER PAINT PROTECTION.
TL* THE CONTACT OWNS A 2004 MAZDA MPV. WHILE THE CONTACT'S WIFE WAS DRIVING 15 MPH, SHE STRUCK ANOTHER VEHICLE ON THE DRIVER'S SIDE DOOR. THE AIR BAGS DID NOT DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN UNKNOWN LOCATION. THE VEHICLE WAS NOT TAKEN TO A DEALER TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT TO SEND DOCUMENTATION FROM THE DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 166,000.
The 2004 Mazda Mpv has 5 NHTSA recalls and 96 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Mazda North American Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2004-2005 MPV, 2004 RX-8, and 2006-2007 Mazdaspeed6 vehicles. These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. The recall began December 3, 2019. Owners may contact Mazda customer service at 1-800-222-5500, option 4. Mazda's number for this recall is 2618F. Note: This recall supersedes recalls 13V130, 14V362, 14V773 and 15V869.
Component: EQUIPMENT:OTHER:LABELS
CERTAIN MINIVANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES WERE PRODUCED WITH AIR BAG WARNING LABELS INTENDED FOR THE CANADIAN MARKET. THUS, THE LABELS CONTAIN WARNINGS IN BOTH ENGLISH AND FRENCH. AS A RESULT, THE AREA OF THE ENGLISH WARNING IS ONLY 16 SQUARE CENTIMETERS, AS OPPOSED TO THE 30 SQUARE CENTIMETERS REQUIRED BY THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH AIR BAG CAUTION LABELS AND INSTALLATION INSTRUCTIONS WHICH WERE MAILED ON JULY 22, 2004. OWNERS SHOULD CONTACT MAZDA AT 1-800-222-5500.
Component: EQUIPMENT:OTHER:LABELS
THE TIRE INFLATION PRESSURE INDICATED ON THE VEHICLE CERTIFICATION LABEL IS NOT CORRECT. THE LABELS SHOW THE MAXIMUM TIRE PRESSURE AS 240 KPA/32 PSI WHEN IT SHOULD BE SHOWN AS 240 KPA/35 PSI. AS A RESULT OF THIS ERROR, THE LOAD RATIOS FOR THE 205/65R15 94H AND THE 215/60R16 95H TIRES EXCEED THE LEVELS PERMITTED BY FMVSS 120.
Consequence: IF THE TIRE IS OPERATED IN AN UNDER-INFLATED CONDITION, THE LOAD CARRYING CAPACITY OF THE VEHICLE MAY BE COMPROMISED, INCREASING THE RISK OF A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH A CORRECTED LABEL THAT THEY CAN APPLY TO THEIR VEHICLE, OR THEY CAN HAVE A DEALER INSTALL THE LABEL, IF DESIRED. THE RECALL BEGAN ON JULY 16, 2004. OWNERS SHOULD CONTACT MAZDA AT 1-800-222-5500, OPTION #4.
Component: AIR BAGS:FRONTAL
AS A RESULT OF AN NCAP TEST, CERTAIN MINIVANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE FRONT PASSENGER SEAT AIR BAG WAS NOT CORRECTLY WIRING.
Consequence: IN THE EVENT OF A CRASH, THE AIR BAG WILL NOT PROVIDE ADEQUATE PROTECTION.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS IN THE FRONT PASSENGER SEAT AIR BAG SYSTEM. THE RECALL BAGAN MARCH 5, 2004. OWNERS SHOULD CONTACT MAZDA AT 1-800-222-5500.
I WENT INTO THE DEALERSHIP TO GET MY SAFETY RECALLS DONE AT THE MAZDA DEALERSHIP ON TORRANCE BUT THEY SAID I NEEDED TO FILL OUT A FORM AND TO WAIT FOR THEM TO RECEIVE THE AUTO PARTS. IT HAS BEEN MORE THAN 6 MONTHS SINCE I WENT, I HAVE NOT HEARD FROM THE AT ALL.
TL* TAKATA RECALL. THE CONTACT OWNS A 2004 MAZDA MPV. THE CONTACT STATED THAT THE RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V354000 (AIR BAGS) WAS RECEIVED IN MAY OF 2016. AFTER CONTACTING THE MANUFACTURER ON MULTIPLE OCCASIONS, THE CONTACT WAS INFORMED THAT THE PARTS NEEDED FOR THE RECALL REMEDY WERE STILL NOT AVAILABLE AND NO ESTIMATED TIME FOR RECEIVING THE PARTS COULD BE PROVIDED. THE LOCAL DEALER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
AIR BAG INFLATOR REPLACEMENT FIRST NOTICE REC.8/1/16,CALLED BOMARITO(LOCAL DEALER)-NO PARTS-WOULD CALL CALLED AGAIN1/2/17-SAME RESPONSE SECOND NOTICE REC.4/17/17-CALLED AGAIN SAME RESPONSE.
TAKATA RECALL: I RECEIVED MAZDA OFFER TO REPLACE DEFECTIVE PART AND ACCOMMODATE FOR TRANSPORTATION WHILE THE CAR IS BEING REPAIR. THE ONLY REQUIREMENT TO HAVE THIS ACCOMMODATIONS IS TO MAKE AN APPOINTMENT FOR THEM TO DELIVER SUCH OFFER TO FIX THE INCONVENIENCES THAT THIS BRINGS. I CALLED TO MAKE THE ARRANGEMENTS BUT NOW MAZDA REFUSES TO GIVE ANOTHER TRANSPORTATION WHILE FIXING THE CAR, EVEN THOUGH THIS IS INCLUDED IN THEIR WRITTEN OFFER.
TL* TAKATA RECALL. THE CONTACT OWNS A 2004 MAZDA MPV. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V354000 (AIR BAGS) HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS UNAVAILABLE.
THERE IS NO WAY TO ADJUSTMENT THE ALIGNMENT OF THE REAR WHEELS ON THIS YEAR MAZDA MPV, THUS THE TIRES WARE OUT EARLY BECAUSE THEY ARE NOT IN ALIGNMENT. TIRE FAILURE OCCURRED WHILE DRIVING ON HIGHWAY MAZDA DEALER SAYS NO ADJUSTMENT CAN BE DONE AS MAZDA DID NOT PROVIDE A WAY TO CORRECT THIS ALIGNMENT PROBLEM SO EARLY TIRE FAILURE CAN RESULT. MAZDA DEALER WORK SHEET FOR ALIGNMENT STATES THAT THE REAR WHEELS ARE OUT OF FACTORY SPECIFICATION AND IF NOT CORRECTED CAN LEAD TO EXCESSIVE TIRE WEAR, HANDLING AND SAFETY ISSUES. MAZDA BY THERE OWN ADMISSION DID NOT PROVIDED ANY WAY TO CORRECT THIS SAFETY ISSUE. I'M DRIVING A VEHICLE WITH TIRE SAFETY ISSUES DUE TO LACK OF ABILITY TO ALIGN THE REAR WHEELS TO MAZDAS OWN SPECIFICATIONS. *TR
TL* TAKATA RECALL. THE CONTACT OWNS A 2004 MAZDA MPV. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V354000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
TL* TAKATA RECALL. THE CONTACT OWNS A 2004 MAZDA MPV. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V354000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
TL* TAKATA RECALL. THE CONTACT OWNS A 2004 MAZDA MPV. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V354000 (AIR BAGS) HOWEVER THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS UNAVAILABLE.
ACCELERATOR (GAS PEDAL) STOCK OPEN WHEN PEDAL PRESSED FOR ACCELERATION ONTO INTERSTATE HIGHWAY. VEHICLE ACCELERATED TO VERY HIGH SPEED. PRESSING BRAKE SLOWED VEHICLE TO 55 MPH. SHIFTED TO NEUTRAL, HEARD A LOW POP AND ACCELERATOR MECHANISM DISENGAGED.
TL* THE CONTACT OWNS A 2004 MAZDA MPV. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V773000 (AIR BAGS); HOWEVER, THE AIR BAG LIGHT CONTINUOUSLY ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.
Showing 15 of 96 complaints