Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 1995 Chevrolet Suburban.
NHTSA has not published 5-star crash-test ratings for the 1995 Chevrolet Suburban. New vehicles are often added to the NCAP rating program after initial release; check nhtsa.gov/ratings for the latest status.
Component: FUEL SYSTEM, GASOLINE
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Component: VISIBILITY:WINDSHIELD WIPER/WASHER
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
1995 CHEVROLET SUBURBAN, CONSUMER WRITES IN REGARD TO WINDSHIELD WIPER MOTOR FAILURE. THE CONSUMER STATED THE DEALER DID NOT HONOR THE RECALL. THE CONSUMER REQUESTED TO BE REIMBURSED FOR THE RECALL REPAIR.
TL* THE CONTACT OWNED A 1995 CHEVROLET SUBURBAN. WHILE DRIVING 60 MPH THE CONTACT NOTICED SMOKE FROM THE REAR OF THE VEHICLE. THE CONTACT PULLED OVER, TURNED OFF THE ENGINE, OPENED THE HOOD, AND NOTICED FLAMES NEAR THE TRANSMISSION AREA. THE FIRE DEPARTMENT WAS CALLED; HOWEVER, THE VEHICLE WAS COMPLETELY BURNED. THE VEHICLE WAS TOWED TO A TOW YARD AND DECLARED A TOTAL LOSS. THE MANUFACTURER WAS NOT NOTIFIED OF THE INCIDENT. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 236,000.
TL* THE CONTACT OWNS A 1995 CHEVROLET SUBURBAN EQUIPPED WITH COOPER DISCOVERER H/T TIRES, SIZE P235/75R15 (NA). WHILE DRIVING 70 MPH, THE REAR PASSENGER SIDE TIRE SEPARATED. THE TIRE WAS REPLACED WITH A SPARE. WHILE DRIVING APPROXIMATELY 70 MPH, THE REAR DRIVER SIDE TIRE BLEW OUT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT THE TIRE TREAD SEPARATED AND NEEDED TO BE REPLACED. THE TIRES WERE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE TIRE FAILURE MILEAGE WAS 12,000 AND THE VEHICLE FAILURE MILEAGE WAS 240,000.
The 1995 Chevrolet Suburban has 7 NHTSA recalls and 515 consumer complaints on file. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
DUE TO A THIN CASE CASTING, AN EXTERNAL TRANSMISSION LEAK CAN OCCUR.
Consequence: THIS CONDITION CAN CAUSE TRANSMISSION OIL TO SPRAYONTO THE EXHAUST SYSTEM AND RESULT IN A POSSIBLE VEHICLE FIRE.
Remedy: DEALERS WILL INSPECT THE TRANSMISSION CASE ASSEMBLY FOR THE INVOLVED CASE CASTING. IF THE ASSEMBLY IS INVOLVED, THE TRANSMISSION WILL BE REPLACED.
Component: VEHICLE SPEED CONTROL
THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.
Component: AIR BAGS
THE VEHICLES HAVE BOTH THE SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) LABEL AND AN ENGINE START LABEL INSTALLED ON THE SAME SIDE OF THE SUN VISOR. THIS DOES NOT COMPLY WITH FMVSS NO.208, "OCCUPANT CRASH PROTECTION."
Consequence: CONSEQUENCE OF NON-COMPLIANCE: OPERATORS COULD FAIL TO NOTICE AND HEED THE WARNING LABEL.
Remedy: THE ENGINE START LABEL WILL BE REMOVED FROM THE STOWED SIDE OF THE SUN VISOR AND A NEW ENGINE START LABEL WILL BE INSTALLED ON THE HEADLINER IN THE SUN VISOR DEPRESSION. OWNERS WILL RECEIVE THE NEW LABEL AND CAN INSTALL THE LABEL THEMSELVES OR HAVE A DEALER INSTALL IT.
Component: POWER TRAIN:AUTOMATIC TRANSMISSION
THE TRANSMISSION SHIFT-CABLE LOCK CLIP CAN BACK OUT OF ITS INSTALLED POSITION RESULTING IN A LOSS OF CABLE ADJUSTMENT. WHEN THE SHIFT LEVER IS PLACED IN THE "PARK" POSITION, THE "PARK" INDICATOR LIGHT MAY NOT ILLUMINATE.
Consequence: THE VEHICLE CAN MOVE UNINTENTIONALLY IF THE DRIVER DOES NOT NOTICE THAT THE INDICATOR LIGHT IS NOT ON AND DOES NOT APPLY THE PARKING BRAKE.
Remedy: DEALERS WILL ADJUST THE SHIFT CABLE AND INSTALL A LOCK CLIP.
Component: VISIBILITY:WINDSHIELD WIPER/WASHER
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
FUEL LEAK AT REAR DRIVER SIDE, IT STOP WHEN TRUCK IS PUT IN PARK. I'M AFRAID OF A FIRE COULD START!!!!!!! *TR
I JUST RECENTLY BEGAN HAVING TROUBLE WITH MY 2000 CHEVY MALIBU AND IT PROMPTED ME TO BEING RESEARCHING COMMON ISSUES WITH CHEVROLET VEHICLES. IN MY RESEARCH I CAME UPON AN INTERESTING FACT THAT SEVERAL MAKES AND MODELS SEEM TO HAVE INTERMITTANT TURN SIGNAL FUNCTIONALITY AND HAZARD LIGHT ISSUES. IN MY CASE MY 1995 CHEVROLET SUBURBAN (WHICH I LOVE MIND YOU) WAS BEING CHECKED FOR A TRAILER TO BE HOOKED UP. WHEN THE PERSON PERFORMING THE INSPECTION ATTEMPTED TO TURN ON THE HAZARD LIGHTS IT CAUSED A MALFUNCTION WITH ALL OF MY TURN SIGNALS, BREAKS, HAZARDS(NO EQUIPMENT WAS ATTACHED TO THE TRUCK SO NO IT WASN'T A FAULTY CONNECTION TO THE TRAILER, THAT HAD NOT BEEN ATTACHED YET.) AFTER SEVERAL MINUTES OF MESSING WITH SIGNALS AND PUSHING BUTTONS IT FINALLY RESET TO NORMAL. THIS FUNNY WIRING PROBLEM OCCURS EVERY TIME I TRY TO TURN ON MY HAZARD LIGHTS. UP TO THIS POINT I HAVE NOT HAD A NEED TO USE THEM BUT I AM AWARE THAT THEY WILL NOT WORK IF I ATTEMPT TO. MY ADVISE TO ANYONE READING THIS IS IF YOU ARE HAVING TROUBLE WITH YOUR TURN SIGNALS MESS WITH THE HAZARD LIGHT BUTTON BEFORE YOU GO REPLACING FLASHERS AND BULBS. IT TOOK SEVERAL TIMES OF PUSHING THE HAZARD BUTTON AND TURNING THE SIGNALS ON AND OFF BEFORE THEY STARTED TO WORK AGAIN. I AM VERY DISAPPOINTED WITH CHEVY THAT THIS ISSUE HAS NOT BE ADDRESS NOW THAT I AM FINDING IT TO SEEM SO COMMON A PROBLEM. I WAS EVEN MORE DISAPOINTED TO LEARN THAT MY MALIBU HAS ISSUES THAT ARE SIMILAR TO OTHERS WITH THAT MAKE AND MODEL AND THOSE ISSUES ARE IGNORED AS WELL. A SIDE NOTE IF YOU READ MY OTHER COMPLAINT. THE 1996 CHEVY S10 MY SPOUSE AND I WERE GOING TO TRADE THE MALIBU FOR ALSO HAS FUEL ISSUES. WHAT A BUMMER I USED TO REALLY LIKE CHEVY. CHANNEL 9 NEWS ANYONE. "NHTSA IT SHOULDN'T TAKE SOMEONE DYING BEFORE YOU MAKE THEM FIX IT. IF IT IS A KNOWN PROBLEM THAT CAN BE PROVEN IS NOT NORMAL WARE THEY SHOULD HAVE TO FIX IT." *TR
TL* THE CONTACT OWNS A 1995 CHEVROLET SUBURBAN. WHILE PARKED, THE CONTACT NOTICED THAT THE FRONT DRIVER'S SIDE SEAT BELT WOULD NOT SUSTAIN HIM PROPERLY WHEN LEANING FORWARD SUDDENLY, AS THE FRONT PASSENGER SIDE SEAT BELT WOULD. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE CONTACT WAS UNAWARE OF THE NECESSARY REPAIR. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
TL*THE CONTACT OWNS A 1995 CHEVROLET SUBURBAN. THE VEHICLE HAS FIRESTONE STEELTEX A/T TIRES, SIZE LT245/70/R16. THE CONTACT NOTICED THAT THE SIDEWALLS WERE SEPARATED ON ALL THE TIRES. HE CALLED THE MANUFACTURER IN REFERENCE TO NHTSA CAMPAIGN ID NUMBER 04T003000 (TIRES) AND WAS REFERRED TO THE DEALER. THE DEALER COULD NOT LOCATE THE RECALL IN THEIR DATABASE; THEREFORE, THE CONTACT WOULD HAVE TO PAY FOR REPLACEMENT TIRES. THE TIRES HAVE NOT BEEN REPLACED AND THE CONTACT STILL HAS THEM IN HIS POSSESSION. THE DOT NUMBER WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 30,000.
(1) HAVE HAD TO REPLACE BRAKING SYSTEM 3 TIMES IN LAST 4 MONTHS (2) VEHICLE KEEPS PULLING TO THE RIGHT AND THE ANTI-LOCK BRAKES HAVE BEEN ACTIVATING FOR NO REASON (3)REPLACED ROTORS, CALIPERS AND BRAKE PADS 3 TIMES IN 4 MONTHS (4)WHEN STARTING FROM START POSITION BRAKE CALIPERS STAY A LITTLE CLOSED AND EVENTUALLY LOOSEN UP ONCE THE VEHICLES PICKS UP SPEED. *JB
CONSUMER 1995 SUBURBAN PAINT IS PEELING OFF THE VEHICLE. *TS *NM
DT: THE CONTACT STATED THE ABS ACTIVATED AT LOW SPEEDS. THE MECHANIC BLED THE BRAKES AND REPLACED THE BRAKE PADS. THE ABS ACTIVATED WHILE DRIVING AROUND A CURVE AT LESS THAN 5 MPH. THE ROADS WERE ICY, AND THE VEHICLE WAS IN 4-WHEEL DRIVE. THE BRAKES LOCKED, BUT THE VEHICLE KEPT MOVING UNTIL IT CRASHED INTO ANOTHER VEHICLE THAT WAS PARKED. THE ABS HAD BEEN ACTIVATED AT LOW SPEEDS SIX MONTHS BEFORE THE ACCIDENT. THE ABS ACTIVATION WAS INTERMITTENT, AND MANY TIMES THE BRAKES WERE DIFFICULT TO DEPRESS. THE VEHICLE IS CURRENTLY AT A DIFFERENT MECHANIC SHOP, WHICH DETERMINED THAT THE PROBLEM MAY BE WITH THE ABS SENSORS. *AK UPDATED 1/11/2006 - THE VEHICLE WAS TAKEN TO THE SERVICE DEALER WHO DETERMINED THAT THE ABS SENSORS WERE CORRODED. THE DEALER CLEANED THE SENSORS AND SPRAYED THE WITH AN ANTI-CORROSION SPRAY. THE CONSUMER HAS FILED A COMPLAINT WITH THE MANUFACTURER. *NM
THE DRIVER NOTICED A BROWNISH LIQUID LEAKING FROM UNDERNEATH THE VEHICLE ONTO THE GROUND WHILE THE VEHICLE WAS PARKED INSIDE OF GARAGE. DRIVER CONTACTED A MECHANIC, AND THE MECHANIC INFORMED THE DRIVER THAT TRANSMISSION NEEDED TO BE REPLACED DUE TO THE HOUSING SHAFT. *AK
THE CONSUMER STATED HE EXPERIENCED THE SAME PROBLEM AS STATED IN RECALL NUMBER 03V527000/STEERING GEAR BEARINGS. UPON TURNING THE STEERING WHEEL AT LOW SPEEDS, IT BECAME DIFFICULT. ALSO, THERE WAS A POPPING NOISE WHEN TURNING THE STEERING WHEEL. PLEASE PROVIDE ANY FURTHER INFORMATION. *JB
MY WHITE 1995 SUBURBAN, WHICH I AM THE ORGIONAL OWNER, PAINT IS FLAKING OFF OF THE VEHICLE. I HAVE SEEN OTHER WHITE CHEVERLOT AND GM VEHICLES DOING THE SAME THING ON THE SIMILAR PARTS OF THE CAR. I WOULD LIKE TO KNOW IF THEIR ARE ANY RECALLS CONCERNING THIS MATTER. *AK
LOSS OF VEHICLE CONTROL ON INTERSTATE HIGHWAY. INADVERTANT LANE CHANGE DURING NOON URBAN TRAFFIC DUE TO SUDDEN MOVEMENT OF DRIVER SEAT TO THE REAR. SEAT COLLAPSE CAUSED BY SEAT SEPARATION AT LEFT FRONT SEAT TRACK ATTACHMENT TO THE BOTTOM OF THE SEAT PAN. MATERIAL FAILURE OF SEAT FRAME RESULTING IN BOLT ATTACHMENT RIPPING FREE OF SHEET METAL SEAT BOTTOM. THE SEAT IS UNSTABLE AND RIGHT FRONT MOUNT FAILURE IS IMINENT. NO REPAIRS ATTEMPTED YET BUT FAILURE APPEARS TO BE WELL KNOWN AND PREVALENT ACROSS ALL GM TRUCK LINES IN 94-96 YEAR GROUP. NOTE: NO OPERATOR OF THIS VEHICLE SINCE 1996 PURCHASE HAS WEIGHED MORE THAN 180 LBS AND THE SEAT HAS NOT BEEN SUBJECTED TO ANY COLLISION OR ABUSE. NORMAL LOADING AND USAGE IS LIGHT TO MODERATE DUTY.
THERE WERE NON EVENTS LEADING UP TO THE UNEXPECTED FAILURE OF MY STANADYNE PUMP MOUNTED DRIVER (FUEL SOLENOID DRIVER). THE FAILURE CAUSED MY 1995 6.5L DIESEL CHEVROLET SUBURBAN TO STALL IN RUSH HOUR TRAFFIC! THIS CAUSED ME TO LOOSE POWER BRAKES AND POWER STEERING. BEING A 3/4 TON PICKUP, THIS WAS NOT A PRETTY PICTURE. THE STALL CAUSED ME TO RUN OFF THE ROAD AND INTO A DITCH. LUCKILY THERE WAS NO ONCOMING TRAFFIC. TO CORRECT THE PROBLEM I INSTALLED A NEW ~$400 STANADYNE PMD. THESE PMDS ARE KNOWN TO GO OUT EVERY 30,000 MILES. THIS IS NOT ACCEPTABLE, AND STANADYNE NEEDS TO DO SOMETHING ABOUT THIS MANUFACTURE FLAW. *NM
Showing 15 of 515 complaints